NHTSA lists 64 complaints for the 2004 BMW X5, 4 of them mention a crash and 10 mention a fire. 5 complaints mention an injury, with 6 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as BMW X5.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
4 recalls.
Date: 2004-08-18. Systems: POWER TRAIN.
Defect: ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
Consequence: THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Do not drive: No. Park outside: No.
Date: 2004-08-13. Systems: FUEL SYSTEM, GASOLINE.
Defect: ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
Consequence: ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK. DEPENDING UPON TRAFFIC AND ROAD CONDITIONS, THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Do not drive: No. Park outside: No.
Date: 2004-07-14. Systems: POWER TRAIN.
Defect: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Consequence: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Do not drive: No. Park outside: No.
Date: 2003-11-14. Systems: POWER TRAIN.
Defect: ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
Consequence: WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS. THE RIGHT OUTPUT SHAFT COULD BECOME DISCONNECTED, AFFECTING THE ABILITY TO CONTROL THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Do not drive: No. Park outside: No.
Manufacturer communications
81 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 26 |
|---|
| ENGINE AND ENGINE COOLING | 19 |
|---|
| EQUIPMENT | 10 |
|---|
| AIR BAGS | 9 |
|---|
| EXTERIOR LIGHTING | 6 |
|---|
| VISIBILITY | 6 |
|---|
| POWER TRAIN | 5 |
|---|
| FUEL SYSTEM, GASOLINE | 4 |
|---|
10249437
Date: 2024-01-16. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, VISIBILITY.
The basic conditions for initializing the power windows are not met.
10249027
Date: 2024-01-11. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle A A?A A A A discharged batteryA A?A A A A compl
10247567
Date: 2023-12-20. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE.
Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, rec
10245422
Date: 2023-11-22. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, EQUIPMENT.
Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleA A?A A A A s equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm L
10244258
Date: 2023-10-20. Type: Service Bulletin/Repair Instructions. Systems: SEATS.
Second seat row blocking access to third seat row, program seat modules. Visible stitching on first row sport seat. Third seat row backrest Bowden cable routing and length change.
10244242
Date: 2023-10-19. Type: Service Bulletin/Repair Instructions. Systems: FORWARD COLLISION AVOIDANCE, LANE DEPARTURE, VEHICLE SPEED CONTROL.
Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
10244239
Date: 2023-10-18. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE, VISIBILITY.
This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
10225110
Date: 2022-09-01. Type: Service Bulletin/Repair Instructions. Systems: SEATS.
The driver's side (left rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail).
10225115
Date: 2022-09-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt power socket plug. Alternatively, it will only operate when constant downward hand pressure is maintained.
10225126
Date: 2022-09-01. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.