NHTSA lists 5 complaints for the 2019 BMW Z4, 1 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as BMW Z4.
Recalls
See new recalls and investigations this week.
6 recalls.
Date: 2025-09-23. Systems: ELECTRICAL SYSTEM.
Defect: BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Consequence: A short circuit in the starter relay may increase the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Do not drive: No. Park outside: Yes.
Date: 2021-08-02. Systems: ENGINE.
Defect: BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Consequence: Loss of braking assist can increase the risk of a crash.
Remedy: Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Do not drive: No. Park outside: No.
Date: 2020-08-27. Systems: EXTERIOR LIGHTING.
Defect: BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence: Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.
Do not drive: No. Park outside: No.
Date: 2020-06-15. Systems: STEERING.
Defect: BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
Consequence: A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
Do not drive: No. Park outside: No.
Date: 2019-10-15. Systems: ENGINE.
Defect: BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i, 330i xDrive, and 2019 Z4 vehicles. The needle roller bearings of the counterbalance shafts may have been improperly installed, potentially causing the counterbalance shaft to loosen.
Consequence: If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Do not drive: No. Park outside: No.
Date: 2019-09-27. Systems: BACK OVER PREVENTION.
Defect: BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50 (excerpt)
Consequence: The lack of an image in the back-up camera display increases the risk of a crash. (excerpt)
Remedy: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371. (excerpt)
Do not drive: No. Park outside: No.
Manufacturer communications
242 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 114 |
|---|
| EQUIPMENT | 94 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 28 |
|---|
| VISIBILITY | 19 |
|---|
| ENGINE AND ENGINE COOLING | 14 |
|---|
| STRUCTURE | 14 |
|---|
| BACK OVER PREVENTION | 11 |
|---|
| ENGINE | 11 |
|---|
11032731
Date: 2026-05-06. Type: Warranty Program/Extension. Systems: ENGINE.
The EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date.
11029010
Date: 2026-02-05. Type: Over The Air. Systems: SUSPENSION.
It was found that the rubber mounts of the wishbone or the tension strut were not correctly pressed in due to a manufacturing fault at the supplier's end. This can lead to an acoustic abnormality in the vehicle.
11013048
Date: 2025-01-13. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
The convertible top does not open or close.
11008101
Date: 2024-09-12. Type: Warranty Program/Extension. Systems: ENGINE.
For this vehicle, the EVAP systems purge (vent) valve limited warranty for defects in materials or workmanship has been extended to 15 years / 150,000 miles as determined from the original in-service date. This coverage is subject to the same vehicle eligibility requirements, limitations, and exclus
11000579
Date: 2024-05-02. Type: Warranty Program/Extension. Systems: ENGINE.
EVAP SYSTEM PURGE (VENT) VALVE EXT LTD WTY (ELW) 15/150
10250374
Date: 2024-02-16. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, VISIBILITY.
An interference noise (groaning noise) can be heard from within the heating and air-conditioning unit in thecenter of the instrument panel. The groaning noise always occurs when either a ventilation flap, air stratification flap or the recirculated airflap moves to a different position. Due to the
10249437
Date: 2024-01-16. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, VISIBILITY.
The basic conditions for initializing the power windows are not met.
10249027
Date: 2024-01-11. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle A A?A A A A discharged batteryA A?A A A A compl
10249018
Date: 2024-01-08. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic acknowledgement (clunk) as seen at the 11 second mark of the vide
10249032
Date: 2024-01-05. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, EQUIPMENT.
The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 A A A A A A A A?A A A A A A A A A A A A A A A A A A A A A A A A?A A A A A A A A A A A A A A A A HU-H: ResetA A A A A A A A?A A A A A A A A A A A A A A A A will be stored in the HU-H3.