NHTSA lists 216 complaints for the 2007 Chevrolet Aveo, 25 of them mention a crash and 13 mention a fire. 15 complaints mention an injury, with 25 injuries and 2 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as CHEVROLET AVEO.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
2 recalls.
Date: 2014-05-19. Systems: EXTERIOR LIGHTING.
Defect: General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Do not drive: No. Park outside: No.
Date: 2006-10-17. Systems: FUEL SYSTEM, GASOLINE.
Defect: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
Consequence: IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Do not drive: No. Park outside: No.
Manufacturer communications
210 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 67 |
|---|
| ENGINE AND ENGINE COOLING | 43 |
|---|
| ELECTRICAL SYSTEM | 38 |
|---|
| POWER TRAIN | 23 |
|---|
| ENGINE | 15 |
|---|
| UNKNOWN OR OTHER | 13 |
|---|
| WHEELS | 13 |
|---|
| AIR BAGS | 12 |
|---|
11021792
Date: 2025-08-07. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/o
11020816
Date: 2025-07-18. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
11019072
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11019073
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11019074
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11009531
Date: 2024-09-27. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
11009088
Date: 2024-09-16. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from
11008956
Date: 2024-09-09. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
11007208
Date: 2024-09-06. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician s
11006621
Date: 2024-08-26. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is com