NHTSA lists 3 complaints for the 2007 Fleetwood Excursion, 0 of them mention a crash and 1 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-07.
NHTSA lists this vehicle as FLEETWOOD EXCURSION.
Model-generated complaint tags: This model year has not been tagged.
Recalls
4 recalls.
Date: 2009-02-18. Systems: ELECTRICAL SYSTEM.
Defect: FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Consequence: THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Remedy: DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Do not drive: No. Park outside: No.
Date: 2008-07-15. Systems: EQUIPMENT.
Defect: FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND F (excerpt)
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE. (excerpt)
Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING O (excerpt)
Do not drive: No. Park outside: No.
Date: 2007-07-18. Systems: STEERING.
Defect: FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Do not drive: No. Park outside: No.
Date: 2007-01-26. Systems: EQUIPMENT.
Defect: CERTAIN MOTOR HOMES FAIL TO COMPLY WITH SECTION 6.2.6, "MARKING OF ALTERNATIVE EXITS," AS REQUIRED BY THE ANSI/NFPA 1192 STANDARD ON RECREATIONAL VEHICLES. THE DINETTE ALTERNATE EXIT/EMERGENCY EGRESS WINDOW IS NOT IDENTIFIED BY AN EXIT LABEL AND RED EGRESS LATCHES. THIS WINDOW IS USED TO EXIT THE MOTOR HOME IN AN EMERGENCY SITUATION AND MUST BE CLEARLY IDENTIFIED.
Consequence: IN THE EVENT OF A CRASH, A PASSENGER MAY NOT KNOW IMMEDIATELY WHERE THE EXIT/ EMERGENCY EGRESS WINDOW WOULD BE LOCATED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT AND REPLACE THE EXISTING BLACK WINDOW LATCH WITH A RED EGRESS WINDOW LATCH AND APPLY THE "EXIT" LABEL TO THE DINETTE ALTERNATIVE EXIT/ EMERGENCY EGRESS WINDOW. THE RECALL BEGAN ON FEBRUARY 15, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Do not drive: No. Park outside: No.
Manufacturer communications
3 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 2 |
|---|
| SERVICE BRAKES, ELECTRIC | 1 |
|---|
10022565
Date: 2009-02-01. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, ELECTRIC.
ACCUMULATION OF MOISTURE INSIDE THE ELECTRIC LEVELER MOTOR BRAKE BOOT. THIS CAUSES CORROSION OF THE LEVELER BRAKE AND SUBSEQUENT SEIZURE OF THE LEVELER MOTOR. FLEETWOOD. *KB UPDATED 7/6/09. *PE
10022825
Date: 2008-02-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
ELECTRIC LEVELERS MAY FAIL TO OPERATE PROPERLY DUE TO AN OPEN CIRCUIT IN THE SENSOR HARNESS, OR A CONTROL MODULE THAT DOES NOT FUNCTION PER DESIGN. *KB UPDATED 6/14/10. *PE
10022211
Date: 2008-01-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
REPLACE THE CONTROLLER FOR POWER GEAR ELECTRIC JACK LEVELERS. *KB UPDATED ON 10/01/07. *NJ UPDATED 4/28/10. *PE