NHTSA lists 2 complaints for the 2001 GEM NEV, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-07.
NHTSA lists this vehicle as GEM NEV.
At a glance
Complaints
2
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
1
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
27,350
Investigations
1
Open investigations
0
Manufacturer communications
4
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
ELECTRICAL SYSTEM
1
50.0%
EXTERIOR LIGHTING
1
50.0%
SERVICE BRAKES, ELECTRIC
1
50.0%
Top subsystems
System
Subsystem
Complaints
ELECTRICAL SYSTEM
WIRING
1
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Defect: ON CERTAIN 2 AND 4 PASSENGER, SHORT AND LONG BED LOW SPEED VEHICLES, THE 12 VOLT OUTPUT FROM THE AUXILIARY CARD CIRCUIT BOARD (A DC VOLTAGE TO DC VOLTAGE CONVERTER) MAY BECOME INOPERATIVE AND RESULT IN LOSS OF HEADLAMP, TAIL LAMP AND TURN SIGNAL LAMP FUNCTIONS.
Consequence: A LOSS OF HEADLAMPS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH. IF THERE IS A LOSS OF TAIL LAMP OR TURN SIGNAL LAMP FUNCTION, A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED OR THAT THE VEHICLE IN FRONT IS TURNING, A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
Do not drive: No. Park outside: No.
Investigations
1 investigations; 0 open.
DP22005
Opened: 2023-01-27. Closed: 2023-08-07.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and ele
Date: 2019-11-20. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, STRUCTURE.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
10220099
Date: 2019-11-20. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
10220101
Date: 2019-11-20. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
10030358
Date: 2009-06-05. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
GEM: INSTALLATION OF THE RIV NUT AS A REPLACEMENT TO THE RUBBER WELL NUT FOR THE FRAMED CANVAS DOOR OPTION. IN THE EVENT OF PART FAILURE, THE RUBBER WELL NUT WILL NEED TO BE REPLACED. *PE
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.