NHTSA lists 6 complaints for the 2002 Honda VFR800, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as HONDA VFR800.
At a glance
Complaints
6
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
2
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
36,046
Investigations
2
Open investigations
0
Manufacturer communications
5
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
ELECTRICAL SYSTEM
5
83.3%
ENGINE AND ENGINE COOLING
1
16.7%
EXTERIOR LIGHTING
1
16.7%
UNKNOWN OR OTHER
1
16.7%
Top subsystems
System
Subsystem
Complaints
ELECTRICAL SYSTEM
WIRING
3
EXTERIOR LIGHTING
HEADLIGHTS
1
EXTERIOR LIGHTING
TURN SIGNAL
1
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Defect: ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER (excerpt)
Consequence: AS A RESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH. (excerpt)
Remedy: DEALERS WILL INSTALL A RE-DESIGNED SUB-HARNESS. IF DAMAGE IS FOUND, THE MAIN WIRING HARNESS WILL ALSO BE REPLACED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON SEPTEMBER 26, 2007. OWNERS WERE RE-NOTIFIED ON NOVEMBER 10, 2007, TO TAKE THEIR MOTORCYCLES TO DEALERS TO HAVE THE PARTS INSTALLED. OWNERS MAY CONTACT HONDA AT 1-866-784-1870. (excerpt)
Date: 2005-01-24. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Consequence: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
Do not drive: No. Park outside: No.
Investigations
2 investigations; 0 open.
AQ12001
Opened: 2012-05-14. Closed: 2013-05-13.
Southern Honda Powersports
NHTSA opened Audit Query (AQ) 12-001 to determine whether Southern Honda Powersports (Southern Honda) of Chattanooga, Tennessee, had complied with the requirements of the National Traffic and Motor Vehicle Safety Act, as amended, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a motor vehicle or equipment manufacturer notify it
Systems: UNKNOWN OR OTHER.
Linked campaign numbers: None listed.
PE05047
Opened: 2005-09-02. Closed: 2005-12-20.
STALLING & SUDDEN HEADLIGHT OUTAGE
ODI OPENED THIS INVESTIGATION AFTER RECEIVING THREE COMPLAINTS CONCERNING ALLEGED ENGINE STALLING AND/OR SUDDEN HEADLIGHT OUTAGES WHILE UNDERWAY.ODI ALSO FOUND NUMEROUS POSTINGS ON A WEB-BASED CHAT BOARD RELATED TO THE SUBJECT VEHICLE AND THESE ALLEGATIONS.FREQUENTLY, THE POSTING REFERENCED THE BLUE CONNECTOR JOINING THE MAIN HARNESS AND THE HEADLIGHT SUB-HARNESS.ODI HAS INSPECTED SUBJECT MOTORCYC
Date: 2014-08-06. Type: Service Bulletin/Repair Instructions. Systems: AIR BAGS.
Dealer message - On Monday, June 23, 2014, American Honda announced three recalls for various 2001-11 Honda models. As of August 4, 2014, affected VINs have been identified, and VIN status inquiry has been updated.
10128559
Date: 2014-07-23. Type: Service Bulletin/Repair Instructions. Systems: AIR BAGS.
Dealer message - On Monday, June 23, 2014, American Honda announced three recalls for various 2001-11 Honda models. As of July 23, 2014, affected VINs have been identified, and service bulletins 14-040, Safety Recall: Accord, Civic, and Others ? Front Passenger?s Airbag Inflator Can Be Over-Pressur
10025523
Date: 2008-05-31. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
LOAD CARRYING CAPACITY REDUCED LABEL FOR ALL HONDA VEHICLES. *PE
10032953
Date: 2008-05-09. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
HONDA: WARRANTY EXTENSION-VEHICLE WARRANTY MILEAGE. CLASS ACTION LAWSUIT ALLEGING THAT THE ODOMETERS ON CERTAIN 2002-2006 HONDA MODELS WERE OVERSTATING MILEAGE. FEDERAL COURT PROVIDED FINAL APPROVAL OF SETTLEMENT ON 12/29/07. NO MODELS LISTED. *PE
10015344
Date: 2005-02-01. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, HYDRAULIC.
LINKED BRAKING SYSTEM (LBS) PROPORTIONAL CONTROL VALVE (PCV) LEAKAGE SAFETY RECALL. *TT
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.