NHTSA lists 1 complaints for the 2004 Itasca Sunstar, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as ITASCA SUNSTAR.
At a glance
Complaints
1
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
3
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
18,461
Investigations
1
Open investigations
0
Manufacturer communications
1
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
ELECTRICAL SYSTEM
1
100.0%
Top subsystems
System
Subsystem
Complaints
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Defect: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWE (excerpt)
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE. (excerpt)
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535. (excerpt)
Defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, MODELS MR1031WB, MR1032BB, MR1033SB, MR1351WB, AND MR1352BB, THE MICROWAVES WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. (excerpt)
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE. (excerpt)
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS W (excerpt)
Defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. (excerpt)
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE. (excerpt)
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS W (excerpt)
Do not drive: No. Park outside: No.
Investigations
1 investigations; 0 open.
EA08002
Opened: 2008-01-04. Closed: 2008-03-14.
ENGINE COOLING FAN BLADE FRACTURE
THE SUBJECT VEHICLES ARE BUILT ON A VOLKSWAGEN EUROVAN CHASSIS AND ARE CLASS C MOTOR HOMES. ON SEPTEMBER 5, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AS RQ 07-002 AFTER RECEIVING FOUR CONSUMER REPORTS OF FAN BLADE FAILURE ON MODEL YEAR 2002 WINNEBAGO RIALTA AND VISTA VEHICLES.AS A RESULT OF ADDITIONAL INFORMATION RECEIVED FROM VOLKSWAGEN IN RESPONSE TO RQ 07-002, TH
Systems: ENGINE AND ENGINE COOLING.
Linked campaign numbers: None listed.
Manufacturer communications
1 manufacturer communications.
Communications by system
System
Count
ENGINE AND ENGINE COOLING
1
10007297
Date: 2004-04-15. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
RADIATOR FAN DAMAGED CAUSED BY IMPROPERLY SUPPORTING THE RADIATOR ASSEMBLY WHEN REPAIRS REQUIRE THE RADIATOR TO BE PIVOTED FORWARD. *TT
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.