NHTSA lists 4 complaints for the 2015 Mercedes-Benz ML400, 1 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 1 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as MERCEDES-BENZ ML400.
Recalls
See new recalls and investigations this week.
5 recalls.
Date: 2022-12-23. Systems: FUEL SYSTEM, DIESEL, FUEL SYSTEM, GASOLINE.
Defect: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML550, 2012-2015 ML350, AMG ML63, 2015 ML250, ML400, 2016 GLE450, GLE300, 2016-2018 GLE350, GLE550, 2016-2019 GLE400, 2017-2019 AMG GLE43, and 2016-2020 AMG GLE63 vehicles. Water might accumulate in the spare tire wheel well and damage the fuel pump control unit, which could cause an engine stall while driving.
Consequence: An engine stall while driving increases the risk of a crash.
Remedy: Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.
Do not drive: No. Park outside: No.
Date: 2019-11-01. Systems: COMMUNICATION.
Defect: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2013-2017 vehicles due to a software fault that may cause the date and time for the emergency call system (eCall) to differ from the actual date and time, potentially relaying an inaccurate vehicle location. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V787-4620.pdf
Consequence: An inaccurate vehicle location may delay emergency responders, increasing the risk of injury.
Remedy: MBUSA has initiated an Over the Air (OTA) remote update. MBUSA will also notify owners, and dealers will check software for a successful OTA or update the communication module software as needed, free of charge. The recall began December 23, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2019120008.
Do not drive: No. Park outside: No.
Date: 2018-04-27. Systems: SUSPENSION.
Defect: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML350 Bluetec 4Matic and ML550 4Matic, 2012-2015 ML63 AMG 4Matic and ML350 4Matic, 2013-2016 GL350 Bluetec 4Matic, GL550 4Matic and GL63 AMG 4Matic, 2017 GLS350d 4Matic, GLS450 4Matic, GLS550 4Matic and GLS63 AMG 4Matic, 2015 ML400 4Matic, 2016 GLE400 4Matic, GLE350 4Matic, GLE63 AMG 4Matic, GLE63S AMG 4Matic, GLE450 4Matic Coupe and G (excerpt)
Consequence: The leaking oil in the presence of an ignition source can increase the risk of a fire. (excerpt)
Remedy: MBUSA will notify owners, and dealers will correct the oil level as necessary and replace the reservoir sealing cap to prevent oil foam from leaking out, free of charge. The recall began August 30, 2018. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2018070015. (excerpt)
Do not drive: No. Park outside: No.
Date: 2016-12-14. Systems: POWER TRAIN.
Defect: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2015 GL350 4Matic Blutec, GL450 4Matic, GL550 4Matic, ML250 Blutec, ML350, ML350 4Matic, ML400 4Matic and 2015-2016 GL63 AMG 4Matic vehicles manufactured September 29, 2014 through March 27, 2015. The affected vehicles have axle bolts on the front and/or rear drive axle carriers that may not have been assembled correctly. As a resul (excerpt)
Consequence: If any of the remaining front or rear axle bolts fracture, the vehicle may be unstable, reducing the handling capability and increasing the risk of a crash. (excerpt)
Remedy: MBUSA will notify owners, and dealers will replace the axle carrier bolts, free of charge. The recall is began February 2017. Owners may contact MBUSA customer service at 1-800-367-6372. (excerpt)
Do not drive: No. Park outside: No.
Date: 2016-06-16. Systems: SEAT BELTS.
Defect: Mercedes-Benz USA, LLC (MBUSA) is recalling certain model year 2015 ML250, ML350, ML350 4Matic, ML400 4Matic, ML63 AMG, and 2016 GLE450 AMG 4Matic vehicles manufactured from April 27, 2015, through May 19, 2015. The affected vehicles may have had the right rear seatbelt anchor bolt incorrectly installed.
Consequence: In the event of a vehicle crash, the right rear seatbelt anchor bolt could fail to secure the passenger, increasing their risk of injury.
Remedy: MBUSA will notify owners, and dealers will inspect and, if necessary, correct the installation of the right rear seat belt anchor bolt, free of charge. The recall began on July 22, 2016. Owners may contact MBUSA customer service at 1-800-367-6372.
Do not drive: No. Park outside: No.
Manufacturer communications
105 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 27 |
|---|
| EXTERIOR LIGHTING | 13 |
|---|
| EQUIPMENT | 12 |
|---|
| POWER TRAIN | 11 |
|---|
| SUSPENSION | 11 |
|---|
| ENGINE AND ENGINE COOLING | 9 |
|---|
| ENGINE | 8 |
|---|
| STRUCTURE | 6 |
|---|
11038186
Date: 2026-09-22. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES.
Complaint Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is similar to a tire or wheel vibration, it is usually readily noticeable that it is distinctly different if it happens at all times or only while braking. Cause Although the cause of the vibra
11037228
Date: 2026-08-28. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
Complaint During part of the steering movement, it feels heavier or more difficult to steer in the same spot every time. OR i??Rattling, humming, dry sliding/gravel noise from the electric steering system when steering (see attachment). Complaint does not impact the ability to safely steer or contro
11036101
Date: 2026-08-06. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Complaint Clanking noise from the area of the speakers in the doors. Cause Under analysis. Remedy To narrow down the cause, first of all remove the door trim. a ? If the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary
11035005
Date: 2026-07-14. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once in each instance when changing direction of travel. Note: Sound file in attachment Cause If the complaint is eliminated by experimentally loosening the outboard collar n
11035003
Date: 2026-07-08. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
Complaint Creaking noise, in irregular sequence when driving slowly in combination with slight steering movements and/or Creaking/crackling noises from the area of the wheel bearing on the front axle when cornering/ maneuvering. Sound file attached for comparison. MUST match noise for proper diagnos
11034932
Date: 2026-07-07. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
Complaint Creaking noise, in irregular sequence when driving slowly in combination with slight steering movements and/or Creaking/crackling noises from the area of the wheel bearing on the front axle when cornering/ maneuvering. Sound file attached for comparison. MUST match noise for proper diagnos
11033185
Date: 2026-05-26. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Complaint After successful commissioning of the HERMES control unit (N112/9) with XENTRY Diagnosis DVD 03/2026, the message "SOS - service not activated" appears on the instrument cluster. In addition, the following two conditions are also met: a ? HERMES (N112/9) control unit: event code B15CE00 is
11032599
Date: 2026-05-12. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
Complaint Creaking noise, in irregular sequence when driving slowly in combination with slight steering movements and/or Creaking/crackling noises from the area of the wheel bearing on the front axle when cornering/ maneuvering. Sound file attached for comparison. MUST match noise for proper diagnos
11031580
Date: 2026-04-16. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING.
Complaint Headlamp, front fog lamp leaky or fogged. Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. If a pressure compensation diaphragm is fitted in the housing cover, then the l
11029959
Date: 2026-03-09. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING.
Complaint Headlamp, front fog lamp leaky or fogged Cause Fogging of the headlamps is a natural phenomenon, which can occur under certain climatic conditions. It does not lead to any technical impairment of the headlamp. If a pressure compensation diaphragm is fitted in the housing cover, then the la