NHTSA lists 891 complaints for the 2005 Nissan Titan, 11 of them mention a crash and 7 mention a fire. 10 complaints mention an injury, with 10 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as NISSAN TITAN.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
4 recalls.
Date: 2010-10-28. Systems: ENGINE AND ENGINE COOLING.
Defect: NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE (excerpt)
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH. (excerpt)
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-03-03. Systems: FUEL SYSTEM, OTHER.
Defect: NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Do not drive: No. Park outside: No.
Date: 2008-06-27. Systems: EQUIPMENT.
Defect: NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Do not drive: No. Park outside: No.
Date: 2006-11-30. Systems: ELECTRICAL SYSTEM.
Defect: ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO (excerpt)
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION I (excerpt)
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261. (excerpt)
Do not drive: No. Park outside: No.
Investigations
1 investigations; 0 open.
PE08037
Opened: 2008-05-30. Closed: 2008-08-25.
ENGINE COMPARTMENT FIRE
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #0
Systems: ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING.
Linked campaign numbers: 08V284000.
Manufacturer communications
107 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 19 |
|---|
| EQUIPMENT | 16 |
|---|
| SUSPENSION | 12 |
|---|
| AIR BAGS | 10 |
|---|
| ENGINE AND ENGINE COOLING | 9 |
|---|
| POWER TRAIN | 8 |
|---|
| SERVICE BRAKES, HYDRAULIC | 7 |
|---|
| STEERING | 7 |
|---|
11036444
Date: 2026-08-24. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
VOLUNTARY SERVICE CAMPAIGN BODY CONTROL MODULE SUB-HARNESS Voluntary Service Campaign ID # P5234 is no longer active. A? Repair orders opened after this bulletina s published date are no longer eligible for reimbursement under Campaign ID # P5234. A? Discard all previous versions of NTB05-086.
11031704
Date: 2026-04-13. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement a Certification Labela or a VIN Plate/Labela may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be
11031705
Date: 2026-04-13. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement a Certification Labela or a VIN Plate/Labela may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be
11009067
Date: 2024-09-23. Type: Service Bulletin/Repair Instructions. Systems: WHEELS.
2004 - 2015 TITAN; VIBRATION AT 40 a 50 MPH This bulletin is no longer active. Please discard previous versions of NTB17-110.
11007000
Date: 2024-09-04. Type: Service Campaign. Systems: AIR BAGS.
VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service His
11004960
Date: 2024-05-21. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
CAN COMMUNICATION CODES a DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
11004961
Date: 2024-05-21. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
CAN COMMUNICATION a NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
11004962
Date: 2024-05-21. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
11001194
Date: 2024-04-30. Type: Service Bulletin/Repair Instructions. Systems: VISIBILITY/WIPER.
REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
11001201
Date: 2024-04-30. Type: Service Bulletin/Repair Instructions. Systems: VISIBILITY/WIPER.
WINDOW GLASS WARRANTY INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.