No complaints are listed for the 2001 Orion V. NHTSA's API and bulk file list none in this build.
Data build 2026-10-07.
NHTSA lists this vehicle as ORION V.
Model-generated complaint tags: No complaints are listed for tagging.
Recalls
5 recalls.
Date: 2010-01-21. Systems: POWER TRAIN.
Defect: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SW (excerpt)
Consequence: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH. (excerpt)
Remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466. (excerpt)
Do not drive: No. Park outside: No.
Date: 2009-10-20. Systems: EQUIPMENT ADAPTIVE/MOBILITY.
Defect: DAIMLER BUSES IS RECALLING CERTAIN MODEL YEAR 2000 THROUGH 2008 ORION TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS. THE LIFTS ARE EQUIPPED WITH A LOGIC BOARD ASSEMBLY FOR THE WHEELCHAIR LIFT CONTROL BOX, P/NOS. 373-0226 AND 373-0265. THE OUTBOARD RAMP BARRIER COULD FOLD IN TOWARD A LIFT PASSENGER AND PINCH, PRESS, OR CRUSH THE PASSENGER'S FEET.
Consequence: THE LIFT PASSENGER COULD BE SERIOUSLY INJURED.
Remedy: ORION WILL NOTIFY OWNERS AND THE REPAIRS WILL BE MADE BY LIFT-U FREE OF CHARGE. PLEASE SEE LIFT-U'S DEFECT REPORT 09E-051. THE SAFETY RECALL BEGAN ON OCTOBER 29, 2009. OWNERS MAY CONTACT LIFT-U AT 1-209-838-2400 OR ORION AT 1-800-716-7466.
Do not drive: No. Park outside: No.
Date: 2004-11-15. Systems: STRUCTURE.
Defect: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." DURING SUBSEQUENT CLOSING OF AN EMERGENCY EXIT THE MOVING WINDOW FRAME INTERFERES WITH THE JAM FRAME STOP LOCATED IN MID SPAN ALONG THE LOWER EDGE OF THE WINDOW FRAME.
Consequence: DURING THE USE OF AN EMERGENCY EXIT WINDOW, A WINDOW MAY NOT OPEN AFTER APPLYING THE REQUIRED FORCES ALLOWING A PERSON TO ESCAPE IN THE EVENT OF AN EMERGENCY.
Remedy: DEALERS WILL INSTALL TWO ALUMINUM BLOCKS EACH ATTACHED BY TWO SCREWS. THE MOVING WINDOW FRAME WILL NOT INTERFERE WITH THE JAM FRAME STOP. THE RECALL BEGAN MAY 1, 2005. OWNERS SHOULD CONTACT ORION AT 905-403-7832, EXT. 3335.
Do not drive: No. Park outside: No.
Date: 2003-03-27. Systems: VISIBILITY.
Defect: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.
Remedy: DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.
Do not drive: No. Park outside: No.
Date: 2001-11-15. Systems: VEHICLE SPEED CONTROL.
Defect: VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS, FIRE TRUCKS, AND TRANSIT BUSES AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN MARCH 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Do not drive: No. Park outside: No.