2016 Peterbilt 330 problems

20V199000

Date: 2020-04-06. Systems: ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES, AIR.

Defect: PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light (excerpt)

Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash. (excerpt)

Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB. (excerpt)

Do not drive: No. Park outside: No.

17V593000

Date: 2017-09-22. Systems: STEERING.

Defect: PACCAR Incorporated (PACCAR) is recalling certain 2016 Peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389G, 567, 579 and 587 trucks and Kenworth K170, T170, T270, T370, T440, T470,T660, T680, T800, T880, and W900 trucks equipped with certain Spicer D or E series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen. (excerpt)

Consequence: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash. (excerpt)

Remedy: PACCAR will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on November 13, 2017. Owners may contact Peterbilt customer service at 1-940-591-4000 or Kenworth cust (excerpt)

Do not drive: No. Park outside: No.

PE20006

Opened: 2020-05-01. Closed: 2024-03-27.

Intermittent Loss of Power Steering Assist

On May 1, 2020, the Office of Defects Investigation (ODI) opened PE20006 to investigate complaints of intermittent loss of power steering assist in Daimler Truck North America (DTNA), Volvo Trucks of North America (Volvo) and PACCAR vehicles equipped with a ZF/TRW (TRW) THP60 steering gear.A The investigation focused on 2010-2020 DTNA Freightliner Cascadia, M2 and WST; Volvo VN, VAH and VHD and P

Systems: STEERING.

Linked campaign numbers: None listed.

11037541

Date: 2026-09-11. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.

"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes. 2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."

11010926

Date: 2024-11-22. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.

Info Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues. A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warran

10219235

Date: 2022-08-03. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES.

The service information for Bendix Air Dryer maintenance is being updated to include new procedures.

10201965

Date: 2021-09-21. Type: Service Bulletin/Repair Instructions. Systems: FUEL SYSTEM, DIESEL.

Fix-As-Fail A?A A Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available. As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by di

10188550

Date: 2021-02-10. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY, VISIBILITY.

Information Only A?A A Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.

10177935

Date: 2020-07-29. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES.

Fix-As-Fail - Bendix New-Gen Lightweight Steer Axle Drum Brake Spider Cracking

10177019

Date: 2020-06-10. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING, STRUCTURE.

Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (A?A A SOCA?A A ) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper

10177021

Date: 2020-06-08. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.

Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.

10176033

Date: 2020-05-29. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.

Information only: Hendrickson Softek front axle maintenance intervals and requirements.

10174764

Date: 2020-04-30. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING, EQUIPMENT ADAPTIVE/MOBILITY, SERVICE BRAKES, AIR, SERVICE BRAKES, HYDRAULIC.

Safety Recall Bulletin: Updated with permanent repair path for phase 1 vehicles. The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power. NHTSA recall number is 18V368. Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.