NHTSA lists 72 complaints for the 2003 Pontiac Sunfire, 4 of them mention a crash and 1 mention a fire. 3 complaints mention an injury, with 3 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as PONTIAC SUNFIRE.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
1 recalls.
Date: 2004-11-01. Systems: EXTERIOR LIGHTING.
Defect: ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, T (excerpt)
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668. (excerpt)
Do not drive: No. Park outside: No.
Investigations
2 investigations; 0 open.
EA04028
Opened: 2004-09-14. Closed: 2004-11-22.
TURN SIGNAL MALFUNCTION
ON MAY 14, 2004 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-043) BASED ON CONSUMER COMPLAINTS ALLEGING THAT THE BRAKE/TAIL TURN SIGNAL LAMPS WOULD NOT OPERATE PROPERLY WHEN EITHER THE TAIL LIGHTS WERE TURNED ON, THE BRAKE PEDAL WAS DEPRESSED, OR WHEN THE TURN SIGNAL SWITCH WAS ACTIVATED.ON SEPTEMBER 14, 2004 ODI UPGRADED PE 04-043 TO AN ENGINEERING ANALYSIS (EA0
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: 04V524000.
PE04043
Opened: 2004-05-14. Closed: 2004-09-14.
TURN SIGNAL MALFUNCTION
COMPLAINANTS ALLEGE THAT THE REAR TURN SIGNALS FAIL TO ILLUMINATE AND DO NOT PROVIDE A SIGNAL TO DRIVERS IN FOLLOWING VEHICLES.ODI HAS RECEIVED ONE REPORT OF A CRASH WHERE THE COMPLAINANT BRAKED AND ATTEMPTED TO MAKE A LEFT TURN AND THE FOLLOWING VEHICLE IMPACTED THE COMPLAINANT'S VEHICLE IN THE DRIVER-SIDE DOOR.IN MAY 2002, GM'S SUPPLIER MADE CHANGES TO THE BULB SOCKET THAT INCLUDED STOPPING THE
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: None listed.
Manufacturer communications
458 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 180 |
|---|
| ELECTRICAL SYSTEM | 68 |
|---|
| ENGINE AND ENGINE COOLING | 62 |
|---|
| POWER TRAIN | 30 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 28 |
|---|
| ENGINE | 24 |
|---|
| UNKNOWN OR OTHER | 19 |
|---|
| VISIBILITY | 17 |
|---|
11020816
Date: 2025-07-18. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
11017252
Date: 2025-03-28. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, UNKNOWN OR OTHER.
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
11014455
Date: 2025-02-20. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to
11009156
Date: 2024-10-25. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester A and Vehicle Data Recorder tools, giving website address and st
11007743
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007744
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007208
Date: 2024-09-06. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician s
11006621
Date: 2024-08-26. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is com
11004557
Date: 2024-06-17. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
11002312
Date: 2024-06-06. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.