NHTSA lists 2 complaints for the 2002 Safari Coach Sahara, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as SAFARI COACH SAHARA.
At a glance
Complaints
2
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
3
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
8,581
Investigations
0
Open investigations
0
Manufacturer communications
2
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
SERVICE BRAKES
2
100.0%
ELECTRICAL SYSTEM
1
50.0%
EQUIPMENT
1
50.0%
POWER TRAIN
1
50.0%
Top subsystems
System
Subsystem
Complaints
EQUIPMENT
APPLIANCE
1
POWER TRAIN
AXLE ASSEMBLY
1
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Defect: ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Date: 2002-10-22. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
Defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
Consequence: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
2 manufacturer communications.
Communications by system
System
Count
ENGINE AND ENGINE COOLING
1
EQUIPMENT
1
10005615
Date: 2003-09-01. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
DURING THE FACTORY INSPECTION PROCESS, IT WAS DETERMINED THAT SOME UNITS COULD POSSIBLY HAVE THEIR LP LINES TOO CLOSE TO THE SLIDE-OUT HARDWARE. AS A PRECAUTION, MONACO COACH IS RECOMMENDING THE LOWERING OF THE LP TANKS TO REDUCE THE CHANGE OF THE SLIDE-OUT HARDWARE RUBBING ON THE LP LINE.
10003083
Date: 2003-08-13. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
JB RADIATOR INNER COOLER FAILURE ON ALUMINUM RADIATORS. *TT
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.