Defect: ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH REYCO REAR AXLE AIR SUSPENSIONS, DEFLATED SUSPENSION AIR BAGS COULD CREATE EXCESSIVE DRIVELINE ANGLES CAUSING U-JOINT DAMAGE.
Consequence: THE DRIVE SHAFT COULD FALL OFF OF THE BUS. FOLLOWING VEHICLES COULD THEN RUN OVER THIS OBSTACLE, INCREASING THE RISK OF DAMAGE TO THE FOLLOWING VEHICLE.
Remedy: DEALERS WILL INSTALL AXLE STOPS TO LIMIT REAR SUSPENSION TRAVEL AND FASTENER TORQUE WILL BE CHECKED ON THE SUSPENSION HEIGHT CONTROL ROD. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Defect: VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES BUILT WITH COMPOSITE FRONT ROOF CAPS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." THE ROOF CAP DOES NOT MEET THE REQUIREMENTS DUE TO THE OMISSION OF THE ADHESIVE THAT JOINS THE ROOF TO THE BUS BODY.
Consequence: IN THE EVENT OF A CRASH, THE ROOF OF THE VEHICLE MAY CRUSH, NOT PROPERLY PROTECTING THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL RE-BOND THE ROOF CAP TO THE ROOF SHEET METAL. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Defect: VEHICLE DESCRIPTION: SCHOOL BUSES. THE ACCELERATOR PEDAL CAN POSSIBLY HANG UP ON THE FLOOR RUBBER.
Consequence: THE DRIVER WOULD BE EXPECTING THE VEHICLE'S SPEED TO DECREASE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A STAINLESS STEEL PLATE UNDER THE ACCELERATOR PEDAL. OWNER NOTIFICATION BEGAN JUNE 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
1 manufacturer communications.
Communications by system
System
Count
SERVICE BRAKES, AIR
1
10036588
Date: 2010-11-29. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.
THOMAS BUILT BUS: ALL MODELS OF THOMAS BUSES USING AUTOMATIC SLACK ADJUSTERS. THE AUTOMATIC SLACK ADJUSTERS ARE ROUTINELY BEING ADJUSTED BY SOME OPERATORS AND SERVICE TECHNICIANS TO MAKE BRAKE PUSHROD STROKE APPEAR TO BE WITH LEGAL BRAKE ADJUSTMENT LIMITS, OR TO COMPENSATE FOR MIS-DIAGNOSED OUT OF
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.