NHTSA lists 2 complaints for the 2019 Blue Bird ALL American, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as BLUE BIRD ALL AMERICAN.
Recalls
See new recalls and investigations this week.
26 recalls. Showing the latest 10 of 26.
Date: 2024-10-11. Systems: EQUIPMENT.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2019-2024 Vision and All American school buses. The emergency exit label operating instructions lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."
Consequence: An emergency exit label that is difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.
Remedy: Dealers will replace the emergency exit label, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Blue Bird Customer Service at 478-822-2242. Blue Bird's number for this recall is R23CK (SB).
Do not drive: No. Park outside: No.
Date: 2024-07-19. Systems: STRUCTURE.
Defect: Blue Bird Bus Company (Blue Bird) is recalling certain 2019-2023 Vision, All American Front Engine, and All American Rear Engine school buses. An exterior roof joint may have been manufactured with insufficient strength that can allow the roof panels to separate in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School B (excerpt)
Consequence: Roof panels that separate during a crash can increase the risk of injury. (excerpt)
Remedy: Dealers will inspect the roof panel joints and install additional rivets as necessary, free of charge. Owner notification letters were mailed September 17, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. (excerpt)
Do not drive: No. Park outside: No.
Date: 2023-11-20. Systems: STRUCTURE.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2014-2024 All American school buses equipped with 39" High Back seat restraining barriers. The bolts securing the restraining barriers to the floor may separate when fully loaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 222, "School Bus Passenger Seating and Crash Protecti (excerpt)
Consequence: An unsecured seat restraining barrier may not properly restrain an occupant during a crash, increasing their risk of injury. (excerpt)
Remedy: Dealers will install a longer bolt with rectangular washer and nut, free of charge. Owner notification letters are expected to be mailed January 16, 2024. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CU-SB. This recall is an expansion of recall number 23V-777. (excerpt)
Do not drive: No. Park outside: No.
Date: 2023-04-18. Systems: POWER TRAIN.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All American and Vision School Buses, equipped with PowerDrive 7000 electric drive systems. The System Control Module (SCM) may activate the anti-rollback feature, causing the vehicle to reverse faster than expected when the vehicle is in reverse and pointing downhill with the brake pedal not applied.
Consequence: A vehicle reversing faster than expected can increase the risk of a crash.
Remedy: Dealers will update the SCM software calibration, free of charge. Owner notification letters were mailed May 10, 2023. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R23CG (SB)
Do not drive: No. Park outside: No.
Date: 2022-07-14. Systems: ELECTRICAL SYSTEM.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American and Vision school buses equipped with Cummins PD7000 Electric Drivetrains containing an electric air compressor. The air compressor housing is improperly grounded, causing electrical voltage greater than 50V AC during operation.
Consequence: An improperly grounded air compressor can cause electric shock, increasing the risk of injury.
Remedy: Dealers will install an electrical ground strap between the compressor motor housing and vehicle chassis, free of charge. Owner notification letters were mailed February 6, 2023. Owners may contact Blue Bird's customer service at 1-478-822-2242. Blue Bird's number for this recall is R22BY-SB.
Do not drive: No. Park outside: No.
Date: 2021-05-04. Systems: FUEL SYSTEM, DIESEL.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect the rail threads and fuel lines, and replace the rail as necessary, free of charge. Owner notification letters were mailed on July 30, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BH-NSB.
Do not drive: No. Park outside: No.
Date: 2021-05-04. Systems: FUEL SYSTEM, DIESEL.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2022 All American buses. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: The remedy for this recall is still under development. Owner notification letters were mailed on July 30, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BH-SB.
Do not drive: No. Park outside: No.
Date: 2021-04-28. Systems: POWER TRAIN, STEERING.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The drivetrain may experience an electromagnetic noise on the Control Area Network (CAN) bus, which may cause a loss of electrical power to the power steering pump.
Consequence: A loss of assisted power steering increases the risk of a crash.
Remedy: Cummins will replace the High Voltage Low Power Inverter Harness, and install an overlay harness, free of charge. Interim owner notification letters were mailed on May 22, 2021. Owner notification letters were mailed on October 25, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242.
Do not drive: No. Park outside: No.
Date: 2021-04-12. Systems: ELECTRICAL SYSTEM.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 Vision and All American school buses. The electric drive train cannot detect isolation faults when the high voltage contactors are closed.
Consequence: An undetected high voltage isolation can expose service personnel to high voltage, increasing the risk of injury.
Remedy: Blue Bird will notify owners, and dealers will update the Vehicle Control Unit software or install a different combination of High Voltage Power Distribution Unit hardware, free of charge. The recall began on May 22, 2021. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R21BD-SB.
Do not drive: No. Park outside: No.
Date: 2020-07-15. Systems: SEAT BELTS.
Defect: Blue Bird Body Company (Blue Bird) is recalling certain 2018-2021 All-American and 2019-2021 Vision school buses. The three-point seatbelt assembly may have been installed without reinforcing washers under the floor at the anchorage point, possibly preventing the assembly from remaining anchored in the event of a crash. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Sta (excerpt)
Consequence: In the event of a crash, seat belt anchorages that do not remain secured increase the risk of injury to those seat occupants. (excerpt)
Remedy: Blue Bird will notify owners, and dealers will inspect the seat belt anchorage point hardware and install any missing hardware as needed, free of charge. This recall began August 11, 2020. Owners may contact Blue Bird customer service at 1-478-822-2242. Blue Bird's number for this recall is R20AX. (excerpt)
Do not drive: No. Park outside: No.
Manufacturer communications
17 manufacturer communications.
Communications by system| System | Count |
|---|
| ENGINE AND ENGINE COOLING | 8 |
|---|
| ELECTRICAL SYSTEM | 5 |
|---|
| EQUIPMENT | 4 |
|---|
| POWER TRAIN | 4 |
|---|
| SEATS | 3 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 2 |
|---|
10240586
Date: 2023-08-11. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING, POWER TRAIN.
A motor high temperature error can display on the instrument cluster when the OEM coolant valve in the closed position restricting coolant flow through the high voltage propulsion motor.
10220363
Date: 2022-09-02. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING, POWER TRAIN.
SM2022 EV Maintenance and Service Documentation This Service Memorandum is to announce information on Cummins Power Electric buses now available at Quickserve Online. Dealer must have access to Quickserve to obtain these service maintenance and repair procedures.
10220365
Date: 2022-09-02. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, POWER TRAIN.
SM2203: EV Recommended Starting Procedure This Service Memorandum is to announce the proper starting procedure to be followed for all Cummins EV powered units. The sequence is required due to multiple electronic modules required to wake up and start communicating over the CAN (Controller Area Netw
10217921
Date: 2022-08-18. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Cummins recently issued Temporary Repair Practice (TRP2484) for certain vehicles with DEF sensor failures in which DEF sensor replacement parts are not available. This provides a temporary ECM calibration that inhibits engine warning messages for communication errors with the DEF sensor allowing con
10201694
Date: 2019-12-11. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Models Affected: 2010 thru 2021 All American Subject: This update provides information on the new surge tank fill necks for All American Instructions: There is a new kit available from Part Sales; 10066291 - Kit, Neck, Surge Tank. This kit is available for use with the All American & TX4 surge
10201697
Date: 2019-12-11. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
The intent of Service Memorandum SM1906 is to make Blue Bird dealers aware that Cummins has released a calibration update improvement to reduce occurrence of A?A A Engine fault codes 3555 and 3556A?A A on Cummins diesel engines with the following base ECM calibrations, "HC80145 thru HC80250 and HB8
10201695
Date: 2019-10-15. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
SM1904: New Ametek Parts & Software New Ametek instrument cluster part numbers and software now listed on the Blue Bird Dealer Vantage website. Also listed is a new Ametek gateway module and applicable software. New Ametek gateway module is only applicable to the Ford Gasoline Vision. Revisions
10201696
Date: 2019-10-15. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
SM1905: Blue Bird Vantage Dash Fault Codes Website Blue Bird Vantage "Dash Fault Codes" website page has been updated to include additional new fault codes for all applicable system types (brake, engine, and transmission). Also, "Powertrain, Ford" has been added to the drop-down tab as a system t
10164994
Date: 2019-09-19. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, EQUIPMENT.
Blue Bird has determined that the CIT brand air conditioning relays should be replaced with Song Chuan brand relays (PN 00079077). Additionally, the wiring harness (PN 10023917) connected to the relay base should be inspected for any sign of damage and replaced, if necessary. Blue Bird will provide
10164993
Date: 2019-09-18. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY.
Overview Blue Bird has determined that the exhaust muffler hanger rods may not be torqued properly. As part of this service bulletin, it is necessary to check the torque on rods to ensure they are torqued in accordance with the provided instructions. If both exhaust hanger rods torque are correct