Defect: ON CERTAIN MOTORCYCLES, THE PLASTIC FUEL PUMP FLANGE COULD COME INTO CONTACT WITH A SUFFICIENT AMOUNT OF ACID OR CHEMICAL COMPOUNDS CONTAINING ACIDIC ELEMENTS, SUCH AS BATTERY ACID OR CERTAIN CLEANING PRODUCTS.
Consequence: THE FLANGE COULD BECOME BRITTLE, CRACK, AND ALLOW FUEL TO ESCAPE FROM THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ACID-RESISTANT CAP OVER THE FUEL PUMP FLANGE. THE RECALL BEGAN JUNE 10, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
9 manufacturer communications.
Communications by system
System
Count
ELECTRICAL SYSTEM
3
EQUIPMENT
3
ENGINE AND ENGINE COOLING
1
EQUIPMENT ADAPTIVE/MOBILITY
1
EXTERIOR LIGHTING
1
FUEL SYSTEM, GASOLINE
1
FUEL SYSTEM, OTHER
1
POWER TRAIN
1
10249027
Date: 2024-01-11. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle A A?A A A A discharged batteryA A?A A A A compl
10205110
Date: 2021-11-24. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, POWER TRAIN.
Ball End Working Loose on Gearshift Lever.
10204667
Date: 2021-09-20. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.
Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to
10193504
Date: 2013-09-09. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Leaks have been reported in fork legs. The cause is reported be from oil lubricating film with accompanying dirt/grease ring is incorrectly interpreted to be a leaking fork leg. Investigations have shown that the part is not defective.
10037025
Date: 2010-08-01. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING.
BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM
10033130
Date: 2009-12-01. Type: Service Bulletin/Repair Instructions. Systems: FUEL SYSTEM, GASOLINE.
BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS
10029624
Date: 2009-03-01. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
BMW MOTORCYCLE: THE COOLANT INLET HOSE IS NOT COMPLIANT WITH THE APPLICABLE BMW SPECIFICATIONS. ENGINE OPERATION CAN CAUSE THE INLET HOSE TO WIDEN AND BECOME CORRESPONDINGLY SHORTER; OVERTIME THIS CONTRACTION IN LENGTH CAN CAUSE THE HOSE TO WORK BACK OFF THE WATER PUMP NOZZLE FOR ENOUGH TO ALLOW COO
10030825
Date: 2007-11-01. Type: Service Bulletin/Repair Instructions. Systems: FUEL SYSTEM, OTHER.
BMW MOTORCYCLE: ENGINE FUELS CONTAINING ETHANOL. BMW MOTORRAD HAS NO OBJECTION TO THE USE OF SI ENGINE FUELS CONTAINING UP TO A MAXIMUM OF 10% ETHANOL AND IMPOSES NO WARRANTY RESTRICTIONS. ETHANOL MIXTURES IN PROPORTIONS HIGHER THAN 10% CAN HAVE AN ADVERSE EFFECT ON PERFORMANCE AND CAN RESULT IN
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.