NHTSA lists 2,330 complaints for the 2006 Chevrolet Cobalt, 164 of them mention a crash and 14 mention a fire. 81 complaints mention an injury, with 196 injuries and 8 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as CHEVROLET COBALT.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
5 recalls.
Date: 2014-04-10. Systems: ELECTRICAL SYSTEM.
Defect: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position. (excerpt)
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occup (excerpt)
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition c (excerpt)
Do not drive: No. Park outside: No.
Date: 2014-02-10. Systems: AIR BAGS, ELECTRICAL SYSTEM.
Defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 200 (excerpt)
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. (excerpt)
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on Apr (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-03-03. Systems: STEERING.
Defect: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Do not drive: No. Park outside: No.
Date: 2009-10-29. Systems: FUEL SYSTEM, GASOLINE.
Defect: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODU (excerpt)
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. (excerpt)
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, L (excerpt)
Do not drive: No. Park outside: No.
Date: 2007-01-18. Systems: STRUCTURE.
Defect: CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Do not drive: No. Park outside: No.
Manufacturer communications
796 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 341 |
|---|
| ELECTRICAL SYSTEM | 188 |
|---|
| ENGINE AND ENGINE COOLING | 92 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 54 |
|---|
| POWER TRAIN | 46 |
|---|
| WHEELS | 39 |
|---|
| ENGINE | 35 |
|---|
| FUEL SYSTEM, GASOLINE | 31 |
|---|
11020816
Date: 2025-07-18. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
11019072
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11019073
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11019074
Date: 2025-05-30. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.
11014455
Date: 2025-02-20. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to
11011782
Date: 2024-12-07. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe
11009156
Date: 2024-10-25. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester A and Vehicle Data Recorder tools, giving website address and st
11007743
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007744
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11008956
Date: 2024-09-09. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).