NHTSA lists 922 complaints for the 2000 Chevrolet Malibu, 45 of them mention a crash and 6 mention a fire. 31 complaints mention an injury, with 36 injuries and 3 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as CHEVROLET MALIBU.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
3 recalls.
Date: 2014-07-03. Systems: ELECTRICAL SYSTEM.
Defect: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Mont (excerpt)
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. (excerpt)
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350. (excerpt)
Do not drive: No. Park outside: No.
Date: 2003-08-28. Systems: EXTERIOR LIGHTING.
Defect: CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Do not drive: No. Park outside: No.
Date: 1999-10-29. Systems: FUEL SYSTEM, GASOLINE.
Defect: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Do not drive: No. Park outside: No.
Investigations
7 investigations; 0 open.
RQ04005
Opened: 2004-06-18. Closed: 2004-11-30.
TURN SIGNAL FAILURES
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO,
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: None listed.
EA02037
Opened: 2002-12-23. Closed: 2003-09-05.
TURN SIGNAL FAILURES
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).G
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: 03V327000.
EA02028
Opened: 2002-09-30. Closed: 2003-12-30.
ERRATIC FUEL GAUGE
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAU
Systems: FUEL SYSTEM, GASOLINE, FUEL SYSTEM, OTHER.
Linked campaign numbers: None listed.
PE02066
Opened: 2002-09-06. Closed: 2003-11-03.
ENGINE STALL DUE TO FUEL STARVATION
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS
Systems: FUEL SYSTEM, GASOLINE, FUEL SYSTEM, OTHER.
Linked campaign numbers: None listed.
PE02064
Opened: 2002-08-22. Closed: 2002-12-23.
TURN SIGNAL FAILURE
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRE
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: None listed.
SQ01002
Opened: 2001-01-26. Closed: 2002-09-30.
ERRATIC FUEL GAUGE
There is no summary currently available
Systems: VEHICLE SPEED CONTROL.
Linked campaign numbers: None listed.
SQ00004
Opened: 2000-02-02. Closed: 2001-01-19.
ACCELERATOR CABLE DETACHES FROM THROTTLE
There is no summary currently available
Systems: VEHICLE SPEED CONTROL.
Linked campaign numbers: None listed.
Manufacturer communications
332 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 105 |
|---|
| ELECTRICAL SYSTEM | 52 |
|---|
| ENGINE AND ENGINE COOLING | 48 |
|---|
| ENGINE | 20 |
|---|
| UNKNOWN OR OTHER | 18 |
|---|
| STRUCTURE | 17 |
|---|
| POWER TRAIN | 16 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 15 |
|---|
11009156
Date: 2024-10-25. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester A and Vehicle Data Recorder tools, giving website address and st
11007743
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007744
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11006621
Date: 2024-08-26. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is com
11006421
Date: 2024-07-24. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions durin
11004761
Date: 2024-06-28. Type: Service Bulletin/Repair Instructions. Systems: ENGINE, FUEL/PROPULSION SYSTEM.
This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
11004557
Date: 2024-06-17. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
11002312
Date: 2024-06-06. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
10251890
Date: 2024-03-13. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
10250775
Date: 2024-02-22. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.