NHTSA lists 18 complaints for the 2000 Ford E-250, 3 of them mention a crash and 2 mention a fire. 2 complaints mention an injury, with 2 injuries and 0 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as FORD E-250.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
5 recalls.
Date: 2009-10-13. Systems: VEHICLE SPEED CONTROL.
Defect: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEA (excerpt)
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING. (excerpt)
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751. (excerpt)
Do not drive: No. Park outside: No.
Date: 2008-02-04. Systems: VEHICLE SPEED CONTROL.
Defect: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Do not drive: No. Park outside: No.
Date: 2007-08-03. Systems: VEHICLE SPEED CONTROL.
Defect: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. (excerpt)
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE. (excerpt)
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS (excerpt)
Do not drive: No. Park outside: No.
Date: 2004-11-26. Systems: EQUIPMENT ADAPTIVE/MOBILITY.
Defect: ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO A WHEELCHAIR OCCUPANT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE WHEELCHAIR SECUREMENT RETRACTORS AS NECESSARY. SURE-LOK WILL HANDLE THE REPAIRS FOR THIS CAMPAIGN. OWNERS SHOULD CONTACT SURE-LOCK AT 1-908-231-1804 OR MOBILITYWORKS AT 1-800-769-8267.
Do not drive: No. Park outside: No.
Date: 2000-09-21. Systems: EQUIPMENT.
Defect: VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT (excerpt)
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS. (excerpt)
Remedy: OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. (excerpt)
Do not drive: No. Park outside: No.
Investigations
2 investigations; 0 open.
EA10003
Opened: 2010-04-13. Closed: 2012-03-05.
HVAC Switch Failures
This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.ODI was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.After a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, ODI did
Systems: ELECTRICAL SYSTEM.
Linked campaign numbers: None listed.
DP05005
Opened: 2005-09-22. Closed: 2006-01-04.
SPARK PLUG EJECTION FROM CYLINDER HEAD
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CY
Systems: ENGINE AND ENGINE COOLING.
Linked campaign numbers: None listed.
Manufacturer communications
30 manufacturer communications.
Communications by system| System | Count |
|---|
| SERVICE BRAKES, HYDRAULIC | 11 |
|---|
| SUSPENSION | 6 |
|---|
| POWER TRAIN | 3 |
|---|
| STEERING | 3 |
|---|
| ENGINE AND ENGINE COOLING | 2 |
|---|
| EXTERIOR LIGHTING | 2 |
|---|
| FUEL SYSTEM, GASOLINE | 1 |
|---|
| FUEL SYSTEM, OTHER | 1 |
|---|
10148820
Date: 2018-04-06. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in steering effort.
10022232
Date: 2006-12-01. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING.
HEADLIGHT ADJUSTMENT NEEDED. *KB
10017865
Date: 2005-07-01. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING.
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
10018941
Date: 2005-01-01. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT
10010743
Date: 2004-10-01. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT
10007350
Date: 2004-01-01. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
CLUNK FROM FRONT SUSPENSION. *TT
10004072
Date: 2003-09-01. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT
637767
Date: 2002-05-01. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, HYDRAULIC.
SUBJECT REGARDING EARLY WEAR OF THE INNER BRAKE PAD ON THE REAR DISC BRAKES. *TT
637519
Date: 2002-04-01. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT
630683
Date: 2002-02-01. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT