NHTSA lists 18 complaints for the 2003 GMC Safari, 1 of them mention a crash and 1 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as GMC SAFARI.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
1 recalls.
Date: 2003-09-12. Systems: SUSPENSION.
Defect: CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO (excerpt)
Consequence: THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE (excerpt)
Remedy: DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. (excerpt)
Do not drive: No. Park outside: No.
Manufacturer communications
406 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 165 |
|---|
| ELECTRICAL SYSTEM | 66 |
|---|
| ENGINE AND ENGINE COOLING | 59 |
|---|
| POWER TRAIN | 28 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 25 |
|---|
| ENGINE | 23 |
|---|
| FUEL SYSTEM, GASOLINE | 14 |
|---|
| WHEELS | 14 |
|---|
11020816
Date: 2025-07-18. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
11014455
Date: 2025-02-20. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to
11009156
Date: 2024-10-25. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester A and Vehicle Data Recorder tools, giving website address and st
11007743
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007744
Date: 2024-09-12. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and ven
11007208
Date: 2024-09-06. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician s
11006621
Date: 2024-08-26. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is com
11006421
Date: 2024-07-24. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions durin
11004761
Date: 2024-06-28. Type: Service Bulletin/Repair Instructions. Systems: ENGINE, FUEL/PROPULSION SYSTEM.
This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
11004557
Date: 2024-06-17. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.