NHTSA lists 884 complaints for the 2016 Hyundai Sonata, 23 of them mention a crash and 31 mention a fire. 13 complaints mention an injury, with 20 injuries and 1 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as HYUNDAI SONATA.
Recalls
See new recalls and investigations this week.
9 recalls.
Date: 2021-09-24. Systems: ELECTRICAL SYSTEM, EXTERIOR LIGHTING.
Defect: Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.
Consequence: A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.
Remedy: Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.
Do not drive: No. Park outside: No.
Date: 2021-08-06. Systems: LATCHES/LOCKS/LINKAGES.
Defect: Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Sonata, 2016-2018 Sonata Hybrid, 2018-2020 Accent, and 2016-2017 Azera vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
Consequence: A person inside the trunk compartment may become trapped, increasing their risk of injury.
Remedy: Dealers will replace the trunk latch base, free of charge. Owner notification letters were mailed December 4, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 208.
Do not drive: No. Park outside: No.
Date: 2020-12-01. Systems: ENGINE.
Defect: Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage. (excerpt)
Consequence: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash. (excerpt)
Remedy: Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is (excerpt)
Do not drive: No. Park outside: No.
Date: 2018-03-12. Systems: HYBRID PROPULSION SYSTEM.
Defect: Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Hyundai Sonata Plug-In Hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.
Consequence: If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will remove the VPD switch and install a new Battery Management System (BMS) that contains an Overvoltage Protection Device (OPD). The recall is expected to begin May 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 175.
Do not drive: No. Park outside: No.
Date: 2017-06-05. Systems: PARKING BRAKE.
Defect: Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Sonata and Genesis vehicles. In the affected vehicles, the warning light to indicate that the parking brake is applied may intermittently not illuminate in the dash due to corrosion in the switch.
Consequence: If the parking brake indicator is not illuminated when the parking brake is applied, the driver may operate the vehicle with the parking brake partially engaged, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the parking brake switch, free of charge. The recall began on August 4, 2017. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 164.
Do not drive: No. Park outside: No.
Date: 2016-10-11. Systems: VISIBILITY.
Defect: Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata Hybrid vehicles manufactured December 8, 2014, to August 18, 2015, and Hyundai Sonata vehicles manufactured May 28, 2014, to March 18, 2016, equipped with the panoramic sunroof option. Due to a bonding issue with the sunroof wind deflector, the sunroof panel on the affected vehicles may detach while driving.
Consequence: If the sunroof detaches from the vehicle it could become a road hazard, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will repair the wind deflector anchor plate, free of charge. The recall began December 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 152.
Do not drive: No. Park outside: No.
Date: 2016-08-24. Systems: AIR BAGS.
Defect: Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Sonata vehicles manufactured March 28, 2016 through April 12, 2016. The affected vehicles have a driver-side frontal air bag that may not adequately protect the driver's neck from injury in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number (excerpt)
Consequence: A frontal air bag that does not adequately protect the driver's neck may increase their risk of injury in the event of a crash. (excerpt)
Remedy: Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began October 14, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 148. (excerpt)
Do not drive: No. Park outside: No.
Date: 2016-04-21. Systems: AIR BAGS.
Defect: Hyundai Motor Company (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 29, 2014 to February 11, 2016, 2017 Elantra vehicles manufactured January 12, 2016 to February 22, 2016, and one 2016 Sonata Hybrid vehicle manufactured October 15, 2015. In these vehicles, the driver's frontal air bag may be missing a chemical enhancer required for the second stage air bag (excerpt)
Consequence: An air bag that does not inflate increases the risk of injury. (excerpt)
Remedy: Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began on May 5,2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 144. (excerpt)
Do not drive: No. Park outside: No.
Date: 2015-10-20. Systems: ELECTRICAL SYSTEM.
Defect: Hyundai Motor America (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 28, 2014, to August 21, 2015. The affected vehicles are equipped with an Antilock Braking System (ABS) warning light intended to warn the driver if there is an ABS malfunction. In the event of an ABS malfunction, the Brake System warning light will illuminate, but the ABS warning light will n (excerpt)
Consequence: If the driver is alerted there is a brake system malfunction, but not specifically with the ABS system, the driver may operate the vehicle unaware that the vehicle's brakes may lock up during hard braking, increasing the risk of a crash. (excerpt)
Remedy: Hyundai will notify owners, and dealers will update the ABS control unit software, free of charge. The recall is expected began on November 30, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 134. (excerpt)
Do not drive: No. Park outside: No.
Investigations
5 investigations; 0 open.
DP22005
Opened: 2023-01-27. Closed: 2023-08-07.
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and ele
Systems: ELECTRICAL SYSTEM.
Linked campaign numbers: 22V063000.
DP22003
Opened: 2022-09-12. Closed: 2023-12-12.
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints i
Systems: ENGINE.
Linked campaign numbers: None listed.
EA21003
Opened: 2021-12-22. Closed: 2024-02-05.
Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles.A During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, inclu
Systems: ENGINE.
Linked campaign numbers: 23V877.
EA19001
Opened: 2019-04-19. Closed: 2024-09-19.
Electrical overstress
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect.A During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicl
Systems: AIR BAGS.
Linked campaign numbers: 20V024.
PE16010
Opened: 2016-09-03. Closed: 2017-02-22.
Electronic Parking Brake
The Office of Defects Investigation opened this investigation on September 3, 2016 based on four reports alleging the rear brakes locked or applied while driving without brake pedal application. One of the reports alleged a fire in the right rear wheel area.The vehicles subject to the investigation are equipped with an optional Electronic Parking Brake (EPB). In this system, an electric motor appl
Systems: SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC.
Linked campaign numbers: None listed.
Manufacturer communications
286 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 100 |
|---|
| ENGINE AND ENGINE COOLING | 68 |
|---|
| EQUIPMENT | 63 |
|---|
| ENGINE | 44 |
|---|
| POWER TRAIN | 28 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 17 |
|---|
| STEERING | 10 |
|---|
| AIR BAGS | 8 |
|---|
11037233
Date: 2026-08-26. Type: Warranty Program/Extension. Systems: UNKNOWN OR OTHER.
Certain vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint
11033699
Date: 2026-05-21. Type: Service Campaign. Systems: ELECTRICAL SYSTEM, ENGINE.
Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. This bulletin provides instructions for updating the Engine Control Module (ECM) to address this condition.
11033700
Date: 2026-05-21. Type: Service Campaign. Systems: ELECTRICAL SYSTEM, ENGINE.
Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. The California Air Resources Board has determined that these vehicles may be releasing air pollutants which exceed Federal and California stan
11033701
Date: 2026-05-19. Type: Service Campaign. Systems: ELECTRICAL SYSTEM, ENGINE.
Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start,
11033705
Date: 2026-05-19. Type: Service Campaign. Systems: ELECTRICAL SYSTEM, ENGINE.
Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start,
11032528
Date: 2026-04-28. Type: Warranty Program/Extension. Systems: UNKNOWN OR OTHER.
Some Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail
11032529
Date: 2026-04-28. Type: Warranty Program/Extension. Systems: UNKNOWN OR OTHER.
Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original ret
11031400
Date: 2026-04-18. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE.
Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.
11031416
Date: 2026-04-14. Type: Service Campaign. Systems: ENGINE.
Certain 2019 a 2020 model year Santa Fe, 2017 a 2018 model year Santa Fe Sport, 2015 a 2019 model year Sonata, and 2018 a 2021 model year Tucson vehicles may exhibit elevated engine-out emissions. Hyundai is conducting a service campaign to update the Engine Control Module (ECM) Software for
11032523
Date: 2026-04-10. Type: Other. Systems: AIR BAGS.
The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous drivera s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the ve