Defect: ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.
Consequence: THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.
Remedy: DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Defect: ON CERTAIN TRUCKS EQUIPPED WITH DT466 OR DT530 1308 STYLE ENGINES AND 4X4 OR 6X6 CAPABILITY, THE UNIVERSAL JOINT BETWEEN THE FRONT DRIVE SHAFT AND DRIVE AXLE COULD COME IN CONTACT WITH THE ENGINE OIL FILTER UNDER CERTAIN BRAKING CONDITIONS.
Consequence: THIS COULD CAUSE A LOSS OF COMPLETE ENGINE OIL WHICH COULD RESULT IN THE ENGINE SHUTTING DOWN AND INCREASE THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR A CRASH.
Remedy: DEALERS WILL INSTALL A SHORTER OIL FILTER AND ADAPTER. OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 29, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
Defect: ON CERTAIN HEAVY DUTY TRUCKS, THE FUEL LINE IS ROUTED TOO CLOSE TO A TURBO CHARGER OUTLET/EXHAUST PIPE. IF AN INTERFERENCE CONDITION OCCURS BETWEEN THE FUEL HARNESS AND THE EXHAUST PIPE, THE FUEL LINE INSIDE THE REFLECTIVE HEAT WRAP COULD MELT DUE TO EXCESSIVE HEAT. (excerpt)
Consequence: THE MELTING OF THE LINE COULD RESULT IN IMMEDIATE ENGINE SHUT DOWN, INCREASING THE RISK OF A CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR PROPER ROUTING OF THE FUEL HARNESS. IF THE HARNESS IS ROUTED NEAR THE EXHAUST SYSTEM, A NEW FUEL HARNESS WILL BE INSTALLED. OWNER NOTIFICATION BEGAN DECEMBER 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-78 (excerpt)
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
88 manufacturer communications.
Communications by system
System
Count
ELECTRICAL SYSTEM
30
ENGINE AND ENGINE COOLING
16
EQUIPMENT
13
UNKNOWN OR OTHER
8
ENGINE
7
SUSPENSION
6
POWER TRAIN
5
STEERING
5
11029461
Date: 2026-02-03. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files. It allows users to quickly load files either manually or directly from the Diamond Logic Builder Vehicles folder using VIN-based selection. As files are added or removed, the comparison runs auto
11028359
Date: 2026-01-02. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
Engine replacements for all International engines will need to follow this procedure.
11027310
Date: 2025-12-19. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle cabs and windshields using an ultrasonic sound detector.
11026148
Date: 2025-12-05. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
This document will guide the user through understanding Prop Shaft Codes and understanding the variations of prop codes. (Metric Prop codes start with the number a 4 and Non metric Prop codes start with a 2.)
11026190
Date: 2025-11-06. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
In some geographic areas, ambient temperatures reaching below 15A?F (-10 A?C), including high levels of humidity, an operator may experience engine stalling, low performance, and or poor aftertreatment performance. This is caused by condensation accumulating and freezing within the Charge Air Cooler
11022447
Date: 2025-08-28. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Title: Service Portal iKNow Feedback Case Types Applies To: All
11022310
Date: 2025-08-25. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
11021609
Date: 2025-07-18. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Title: A/C Refrigerant and Oil Capacities Applies To: All current models
11021606
Date: 2025-07-17. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
11021607
Date: 2025-07-07. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of Conformance and/or Clean Idle Sticker, Clean Truck Check
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.