NHTSA lists 7 complaints for the 2010 International Prostar, 1 of them mention a crash and 1 mention a fire. 1 complaints mention an injury, with 2 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as INTERNATIONAL PROSTAR.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
10 recalls.
Date: 2023-05-18. Systems: EXTERIOR LIGHTING.
Defect: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 (excerpt)
Consequence: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash. (excerpt)
Remedy: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514. (excerpt)
Do not drive: No. Park outside: No.
Date: 2014-10-31. Systems: ELECTRICAL SYSTEM.
Defect: Navistar, Inc. (Navistar) is recalling certain model year 2010-2015 International Lonestar vehicles manufactured October 12, 2009, to June 16, 2014, and 2009-2015 International ProStar vehicles manufactured December 16, 2008, to June 20, 2014. In the affected vehicles the electrical harness that supplies power to the HVAC system may not be of sufficient size for the electrical load of the circuit (excerpt)
Consequence: An increase in resistance and heating at the connectors could cause a vehicle fire. (excerpt)
Remedy: Navistar will notify owners, and dealers will replace the 60 amp relay and battery harness with a 150 amp relay and battery harness, free of charge. Navistar issued an interim notification to owners on December 29, 2014. The recall began on March 2, 2015. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 14516. (excerpt)
Do not drive: No. Park outside: No.
Date: 2013-09-18. Systems: EQUIPMENT, TRAILER HITCHES.
Defect: Navistar, Inc. is recalling certain model year 2008-2013 International LoneStar, ProStar, and TranStar trucks manufactured February 20, 2008, through July 29, 2013 and equipped with an electronic fifth wheel jaw release system (feature code 0595BAW or 0595BAY). Due to an assembly error, the air lines at the isolation/vent valve may not be oriented correctly.
Consequence: Because of the improper orientation, in the event of an air leakage at the isolation/vent valve, the 5th wheel jaw may release, unexpectedly releasing the trailer from the tractor, increasing the risk of a vehicle crash.
Remedy: Navistar will notify owners, and dealers will inspect the air line routing. If necessary, the air line routing will be corrected free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-331-332-1590. Navistar's recall number is 13514.
Do not drive: No. Park outside: No.
Date: 2012-05-02. Systems: ELECTRICAL SYSTEM.
Defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2013 PAYSTAR, WORKSTAR, TRANSTAR, AND PROSTAR, AND MODEL YEAR 2012 AND 2013 LONESTAR COMMERCIAL TRUCKS MANUFACTURED FROM JUNE 1, 2009, THROUGH APRIL 4, 2012, EQUIPPED WITH A MAXXFORCE 11 OR 13 ENGINE (FEATURE CODE 12UXJ OR 12UXH) AND WITH BOSCH ALTERNATOR FEATURE CODES 08GGN, 08GGR, 08GHG, OR 08GHH. THE ALTERNATOR CABLE MAY RUB ON THE HIGH PRE (excerpt)
Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH. (excerpt)
Remedy: NAVISTAR WILL INSTALL A STANDOFF BRACKET AND IMPROVE HARNESS ROUTING TO BETTER ROUTE THE ALTERNATOR WIRES AWAY FROM THE POWER STEERING HOSE. THE SAFETY RECALL BEGAN ON JULY 16, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825. (excerpt)
Do not drive: No. Park outside: No.
Date: 2011-08-17. Systems: ELECTRICAL SYSTEM.
Defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2010-2012 PAYSTAR, WORKSTAR, TRANSTAR, AND PROSTAR COMMERCIAL TRUCKS MANUFACTURED FROM JUNE 1, 2009, THROUGH MAY 31, 2011, EQUIPPED WITH A MAXXFORCE 11 OR 13 ENGINE (FEATURE CODE 12UXJ OR 12UXH) AND WITH ALTERNATOR FEATURE CODE 08GGN, 08GGR, 08 GHG, OR 08GHH. THE ALTERNATOR CABLE MAY RUB ON THE HIGH PRESSURE POWER STEERING HOSE, POSSIBLY CHAFING ITS INSUL (excerpt)
Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH. (excerpt)
Remedy: NAVISTAR WILL INSTALL A BRACKET TO ROUTE THE WIRES AWAY FROM THE POWER STEERING HOSE. NAVISTAR DID NOT PROVIDE AN EXPECTED START DATE FOR THE RECALL, BUT AN INTERIM NOTICE WILL BE MAILED TO OWNERS IF PARTS WILL NOT BE AVAILABLE UNTIL AFTER OCTOBER 14, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY 12V-196. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-08-24. Systems: VISIBILITY.
Defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 INTERNATIONAL PROSTAR AND LONESTAR HEAVY TRUCKS MANUFACTURED FROM JANUARY 2, 2007 THROUGH JUNE 1, 2010. THE PASSENGER SIDE WINDSHIELD WIPER LINKAGE ROD MAY SEPARATE FROM EITHER THE WIPER DRIVE ARM OR PASSENGER SIDE PIVOT ASSEMBLY.
Consequence: WHEN THE LINKAGE SEPARATES, THE PASSENGER SIDE WIPER ARM WILL NO LONGER OPERATE WHICH COULD LEAD TO REDUCED DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: NAVISTAR WILL NOTIFY OWNERS AND INTERNATIONAL DEALERS WILL REPLACE THE WINDSHIELD WIPER LINKAGE ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 17, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
Do not drive: No. Park outside: No.
Date: 2010-06-14. Systems: STEERING.
Defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 INTERNATIONAL 4300M, 8600, LONESTAR AND PROSTAR BRAND TRUCKS MANUFACTURED FROM MAY 6, 2009 THROUGH MAY 25, 2010. THE FASTENER THAT CLAMPS THE PITMAN ARM TO THE STEERING GEAR SHAFT MAY HAVE BEEN UNDERTORQUED UPON ASSEMBLY. AN UNDER TORQUE CONDITION MAY CAUSE WEAR OF THE INTERCONNECTING SPLINES OF THE ARM AND THE SHAFT POSSIBLY ALLOWING THE PI (excerpt)
Consequence: A REDUCTION OF STEERING CONTROL INCREASES THE RISK OF A CRASH. (excerpt)
Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-03-18. Systems: ELECTRICAL SYSTEM.
Defect: NAVISTAR HAS NOTIFIED NHTSA OF A DEFECT ON CERTAIN MODEL YEAR 2008-2011 INTERNATIONAL TRUCKS EQUIPPED WITH AN OPTIONAL JUMP START STUD. CORROSION AT THE BASE OF THE STUD MAY CAUSE AN ELECTRICAL SHORT BETWEEN THE STUD AND BATTERY BOX.
Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE.
Remedy: A FINAL REMEDY HAS BEEN ESTABLISHED. NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES BY INSTALLING A NEW JUMP START STUD. REPAIRS WILL BE PREFORMED FREE OF CHARGE. AN INTERIM ACTION WILL INVOLVE THE REMOVAL OF THE JUMP START STUD AND THE CONNECTING CABLE. THE SAFETY RECALL BEGAN ON SEPTEMBER 10, 2010. OWNERS MAY CONTACT INTERNATIONAL DEALERS AT 1-800-448-7825.
Do not drive: No. Park outside: No.
Date: 2010-02-03. Systems: ELECTRONIC STABILITY CONTROL (ESC).
Defect: NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009-2010 INTERNATIONAL PROSTAR AND LONESTAR TRUCKS EQUIPPED WITH FEATURE CODE 04AZT ROLL STABILITY CONTROL. THE AIR LINE THAT SUPPLIES THE TRACTION SOLENOID VALVE OF THE ROLL STABILITY CONTROL (RSC) SYSTEM MAY HAVE BEEN CONNECTED TO AN INCORRECT PORT ON THE AIR TANK. THIS CONDITION WILL AFFECT AIR MODULATION TO THE TRAILER BRAKES IF RSC IS ACTIVATED DURIN (excerpt)
Consequence: LESS THAN OPTIMAL RSC CONTROL OF THE TRAILER BRAKES DURING A ROLL STABILITY EVENT MAY INCREASE THE RISK OF A CRASH WHICH CAN RESULT IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH. (excerpt)
Remedy: DEALERS WILL INSPECT AND RELOCATE THE AIR LINE THAT SUPPLIES THE RSC TRACTION SOLENOID VALVE TO THE CORRECT PORT ON THE AIR TANK. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 19, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825. (excerpt)
Do not drive: No. Park outside: No.
Date: 2008-11-24. Systems: SERVICE BRAKES, AIR.
Defect: NAVISTAR IS RECALLING 14,048 MY 2008-2010 LONESTAR AND PROSTAR TRUCKS. THE SERVICE BRAKE AIR LINE THAT RUNS FROM THE TRACTOR PROTECTION VALVE TO THE FAST BRAKE MODULE MAY SEPARATE FROM THE FAST BRAKE MODULE RESULTING IN LOSS OF TRAILER SERVICE BRAKES.
Consequence: LOSS OF TRAILER SERVICE BRAKES MAY CAUSE A CRASH RESULTING IN POSSIBLE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
Remedy: DEALERS WILL REPLACE THE FAST BRAKE MODULES AND THE AIR LINES RUNNING TO THE MODULE WILL BE REROUTED TO ELIMINATE LINE TENSION CAUSED BY CAB TO FRAME RELATIVE MOTION. THE RECALL BEGAN ON MARCH 20, 2009. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.
Do not drive: No. Park outside: No.
Manufacturer communications
479 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 122 |
|---|
| ELECTRICAL SYSTEM | 120 |
|---|
| ENGINE AND ENGINE COOLING | 89 |
|---|
| ENGINE | 36 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 33 |
|---|
| STRUCTURE | 29 |
|---|
| POWER TRAIN | 21 |
|---|
| VISIBILITY | 21 |
|---|
11035951
Date: 2026-07-24. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
The new clusters in the post-2007 models store the mileage in memory. When replacing the cluster, follow these instructions to program the current vehicle mileage into the memory of the new cluster.
11032505
Date: 2026-04-25. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE.
This document enables technicians to: 1. Accurately identify second generation MaxxForce medium duty engine control systems. 2. Understand the programming intricacies related to these systems. 3. Autonomously execute programming tasks without needing technical support.
11028361
Date: 2026-02-05. Type: Other. Systems: ENGINE.
New CARB Idle Reduction Change Request
11029461
Date: 2026-02-03. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files. It allows users to quickly load files either manually or directly from the Diamond Logic Builder Vehicles folder using VIN-based selection. As files are added or removed, the comparison runs auto
11028356
Date: 2026-01-16. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
This document will guide the user through Mass Air Flow (MAF) calibration procedure
11028359
Date: 2026-01-02. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
Engine replacements for all International engines will need to follow this procedure.
11027310
Date: 2025-12-19. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
This document will guide the user through a step-by-step procedure for detecting water leaks in vehicle cabs and windshields using an ultrasonic sound detector.
11027312
Date: 2025-12-19. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This document provides: Steps to take when switch pack programming fails, or when switch pack disappears after body control module update Sample scenarios Additional information to assist readers in understanding DLB switch pack programming
11027306
Date: 2025-12-18. Type: Service Bulletin/Repair Instructions. Systems: FUEL/PROPULSION SYSTEM.
This document describes the process for utilizing the CPA High Pressure Fuel Pump (HPFP) Test
11027309
Date: 2025-12-18. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
In some geographic areas, ambient temperatures reaching below 40A?F (4A?C), including high levels of humidity, an operator may experience engine stalling, low performance, and/or poor aftertreatment performance. This is caused by condensation accumulating and freezing within the Charge Air Cooler (C