NHTSA lists 1 complaints for the 2010 Kenworth T800, 0 of them mention a crash and 1 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as KENWORTH T800.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
11 recalls. Showing the latest 10 of 11.
Date: 2024-02-23. Systems: SERVICE BRAKES, AIR.
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2012-2021 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2009-2020 Kenworth T370, 2014-2023 Kenworth T880, 2011-2016 Kenworth T470, 2023 Kenworth T480, and 2009-2019 Kenworth W900 vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehi (excerpt)
Consequence: Insufficient air volume can reduce braking performance and increase the risk of a crash. (excerpt)
Remedy: Dealers will install the correct volume air tanks, free of charge. Owner notification letters were mailed August 12, 2024. Additional owner notification letters were mailed October 27, 2025. Owners may contact PACCAR customer service at 1-425-828-5888. PACCAR's number for this recall is 24KWD. (excerpt)
Do not drive: No. Park outside: No.
Date: 2020-04-06. Systems: ELECTRONIC STABILITY CONTROL (ESC), SERVICE BRAKES, AIR.
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light (excerpt)
Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash. (excerpt)
Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB. (excerpt)
Do not drive: No. Park outside: No.
Date: 2015-05-26. Systems: ENGINE AND ENGINE COOLING.
Defect: PACCAR Incorporated (PACCAR) is recalling certain model year 2010-2016 Kenworth T440, T800, and W900 trucks manufactured August 31, 2009, to April 20, 2015, and 2008-2015 Peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured July 27, 2007, to April 28, 2015, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the (excerpt)
Consequence: If engine oil comes into contact with a hot surface, there is an increased risk of a fire. (excerpt)
Remedy: Cummins will notify owners on behalf of PACCAR, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. (excerpt)
Do not drive: No. Park outside: No.
Date: 2013-11-18. Systems: SERVICE BRAKES.
Defect: PACCAR is recalling certain model year 2007-2014 Kenworth T800 and W900 trucks manufactured March 22, 2006, through July 15, 2013 and equipped with Primaax tridem rear suspensions and a pusher and/or tag axle. The affected trucks have brake chambers that take longer to apply or release the brakes than the required time limit. Thus, these vehicles fail to conform to the requirements of Federal Mot (excerpt)
Consequence: Brakes that take longer to apply may lengthen the distance needed to stop the truck, increasing the risk of a crash. (excerpt)
Remedy: PACCAR will notify owners, and dealers will modify the air brake system, free of charge. The recall began on January 15, 2014. Owners may contact PACCAR at 1-425-468-7400. Kenworth's recall number is 13KWL. (excerpt)
Do not drive: No. Park outside: No.
Date: 2011-02-23. Systems: FUEL SYSTEM, OTHER.
Defect: PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2012 KENWORTH T2000, T660, T700, T800, AND W900, AS WELL AS MODEL YEAR 2009-2012 PETERBILT 365, 367, 384, 386, 387, 388, 389, AND 587 TRUCKS EQUIPPED WITH PACCAR MX ENGINES. THE OIL MODULE CENTRIFUGAL SPINNER FILTER CAP IN THE PACCAR MX ENGINE MAY BECOME LOOSE, POSSIBLY ALLOWING THE CAP TO COME OFF AND ENGINE OIL TO PARTIALLY DISCHARGE FROM THE OIL MODU (excerpt)
Consequence: THE DISCHARGE OF ENGINE OIL ONTO EXHAUST COMPONENTS WHICH ARE HOT, SUCH AS WHEN THE ENGINE IS UNDER SIGNIFICANT LOAD, MAY CAUSE A FIRE. (excerpt)
Remedy: DEALERS WILL RE-TORQUE THE OIL MODULE FILTER CAP AND INSTALL A SECONDARY RETENTION DEVICE ON THE SECONDARY CENTRIFUGAL SPINNER FILTER CAP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-10-27. Systems: SERVICE BRAKES, AIR.
Defect: PACCAR IS RECALLING CERTAIN MODEL YEAR KENWORTH T660, T700, T800 AND W900 VEHICLES MANUFACTURED FROM DECEMBER 22, 2008, THROUGH AUGUST 2, 2010, AND EQUIPPED WITH AG400L AIR DISC BRAKES. THE AIR DISC BRAKE CALIPER COULD BE INSTALLED ON THE WRONG SIDE OF THE DRIVE AXLE POTENTIALLY CAUSING INTERFERENCE WITH THE SUSPENSION BRACKET AND THE REAR SUSPENSION AS THE OUTERMOST BRAKE PADS WEAR AND THE FLOAT (excerpt)
Consequence: AS THIS INTERFERENCE GETS LARGER, THIS COULD EVENTUALLY LEAD TO REDUCED BRAKING PERFORMANCE, INCREASING THE RISK OF A CRASH. (excerpt)
Remedy: DEALERS WILL VERIFY THE CORRECT ORIENTATION OF THE BRAKE CALIPER AND PERFORM THE NECESSARY REPAIR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT KENWORTH AT 425-828-5440. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-07-02. Systems: STEERING.
Defect: PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2010 TRUCKS EQUIPPED WITH TRW STEERING SHAFTS. THE CIRCUMFERENTIAL WELD AROUND THE STEERING SHAFT TUBE THAT WELDS THE SPLINED TUBE TO THE NON-SPLINED TUBE MAY BE MISLOCATED. MISLOCATION OF THE CIRCUMFERENTIAL WELD MAY ALLOW THE SPLINED TUBE AND NON-SPLINED TUBE TO ROTATE RELATIVE TO ONE ANOTHER DURING A LOW SPEED, HIGH TORQUE TURN, POSSIBLY RESULTING I (excerpt)
Consequence: A SEPARATION OF THE SPLINED AND NON-SPLINED TUBES WOULD CAUSE A LOSS OF STEERING CONTROL AND INCREASE THE RISK OF A VEHICLE CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT THE STEERING SHAFT USING A WELD PLACEMENT GAUGE PROVIDED BY TRW. ANY STEERING SHAFT FOUND TO HAVE BEEN WELDED IMPROPERLY WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 30, 2010. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 940-591-4196. (excerpt)
Do not drive: No. Park outside: No.
Date: 2010-05-04. Systems: SUSPENSION.
Defect: KENWORTH IS RECALLING CERTAIN MODEL YEAR 2010 T2000, T660, T800 AND W900 VEHICLES MANUFACTURED BETWEEN JULY 30, 2009 AND SEPTEMBER 18, 2009. THE REAR AXLE OUTER END HUB MAY HAVE NOT BEEN PRIMED WITH OIL PROPERLY DURING THE REAR AXLE INSTALLATION PROCESS. POTENTIAL LACK OF OIL MAY CAUSE THE OUTER END BEARING TO HEAT UP AND/OR SEIZE, POSSIBLY RESULTING IN THE OVERHEATING OF THE WHEEL END.
Consequence: A WHEEL END FIRE MAY OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BEARINGS, SEALS AND WILL ADD OIL TO THE OUTER END HUB AS WELL AS INSPECT RACES AND AXLE HOUSING FOR DAMAGE AND REPLACING AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 24, 2010. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.
Do not drive: No. Park outside: No.
Date: 2009-12-23. Systems: STEERING.
Defect: KENWORTH IS RECALLING MODEL YEAR 2010 T2000, T800, T660 AND W900S TRUCKS MANUFACTURED BETWEEN JULY 1 AND OCTOBER 23, 2009. THE FASTENERS ATTACHING THE STEERING GEAR TO THE FRONT DRIVE BRACKET MAY HAVE RECEIVED INSUFFICIENT TORQUE DURING THE INSTALLATION PROCESS RESULTING IN LESS THAN REQUIRED CLAMP LOAD.
Consequence: THE INSUFFICIENT CLAMP LOAD MAY ALLOW THE FASTENER(S) TO BECOME LOOSE AND FALL AWAY FROM THE VEHICLE RESULTING IN ROAD DEBRIS. IF MULTIPLE FASTENERS WERE TO BECOME LOOSE, THE VEHICLE STEERING MAY WANDER, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND RE-TORQUE THE STEERING GEAR MOUNTING BOLTS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440.
Do not drive: No. Park outside: No.
Date: 2009-10-21. Systems: POWER TRAIN.
Defect: KENWORTH IS RECALLING MODEL YEAR 2009 THROUGH 2010 T2000, T800, T660 AND W900 TRUCKS MANUFACTURED BETWEEN NOVEMBER 12, 2008 AND SEPTEMBER 30, 2009. THE AXLE U-BOLTS ATTACHING THE AXLE TO THE SUSPENSION LEAF SPRING ON CERTAIN AG400L REAR SUSPENSIONS MAY HAVE RECEIVED INSUFFICIENT FASTENER TORQUE DURING THE INSTALLATION PROCESS. THE INSUFFICIENT TORQUE MAY ALLOW THE AXLE U-BOLT TO BECOME LOOSE, WH (excerpt)
Consequence: IF MULTIPLE FASTENERS WERE TO BECOME LOOSE, THE REAR AXLE MAY SHIFT RELATIVE TO THE REAR SUSPENSION LEAF SPRING, WHICH CAN RESULT IN LOSS OF CONTROL AND A CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT THE AXLE U-BOLTS FOR VISIBLE DEFECTS, INCLUDING BENT AND/OR SMASHED THREADS AND RE-TORQUE THE AXLE U-BOLTS TO FACTORY SPECIFICATIONS. THE RECALL BEGAN ON NOVEMBER 4, 2009. OWNERS MAY CONTACT KENWORTH AT 425-828-5440. (excerpt)
Do not drive: No. Park outside: No.
Manufacturer communications
59 manufacturer communications.
Communications by system| System | Count |
|---|
| ENGINE AND ENGINE COOLING | 30 |
|---|
| ELECTRICAL SYSTEM | 12 |
|---|
| EQUIPMENT | 6 |
|---|
| ENGINE | 4 |
|---|
| FUEL SYSTEM, GASOLINE | 4 |
|---|
| FUEL SYSTEM, OTHER | 4 |
|---|
| POWER TRAIN | 2 |
|---|
| SEATS | 2 |
|---|
11037541
Date: 2026-09-11. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes. 2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
10254164
Date: 2024-04-09. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.
Certain C500/T440/T470/T660/T680/T800/T880/W900 chassis may have air tank reservoirs that do not meet air volume requirements per FMVSS/CMVSS 121 A A?A A A A Air Brake SystemsA A?A A A A . This bulletin will be updated when repair parts and procedures are available.
10188550
Date: 2021-02-10. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY, VISIBILITY.
Information Only A?A A Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
10177021
Date: 2020-06-08. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
10173205
Date: 2020-03-17. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
10173212
Date: 2020-03-03. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL.
Information Only A?A A Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
10168703
Date: 2019-11-06. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
10056911
Date: 2015-02-27. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
KENWORTH: SOME TRUCKS FAILED TO MEET COMPANY STANDARDS FOR AIR VOLUME LIFT AXLE AND THE COMPANY WILL INCREASE AIR VOLUME FOR WORTHWHILE IMPROVEMENT TO EXCEED GOVERNMENT FMVSS 121. MODEL T800, W900. *PE
10055926
Date: 2014-05-09. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
KENWORTH: PROCEDURAL INFORMATION PROVIDED REGARDING THE REPLACEMENT OF HOOD WHERE THERE ARE DAMAGED HOOD POCKETS. MODEL T800. *PE
10051834
Date: 2013-02-04. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING.
MX RC5-RC14 SOFTWARE UPDATE CAMPAIGN. SOFTWARE UPDATES ARE SAID TO BENEFIT THE ENGINES IN RC5 AND RC14 KENWORTH ENGINES. PACCAR/KENWORTH. *KB