NHTSA lists 2 complaints for the 2025 Mercedes-Benz G 580 EV, 0 of them mention a crash and 0 mention a fire. 1 complaints mention an injury, with 1 injuries and 0 deaths reported.
Data build 2026-10-10.
NHTSA lists this vehicle as MERCEDES-BENZ G 580 EV.
Model-generated complaint tags
These labels are model-generated, not NHTSA data.
Failure modes| Label | Count | Share of tagged | Mean confidence |
|---|
| mechanical failure | 2 | 100.0% | 1.00 |
|---|
Severities| Label | Count | Share of tagged | Mean confidence |
|---|
| moderate | 2 | 100.0% | 0.94 |
|---|
Model: typesafe/jev-1.13-20260917; schema version: tag-v1. 2 tagged complaints of 2 complaints (100.0%).
Confidence is the model's own probability for the label it chose (0 to 1), not accuracy.
Model-generated labels on tagged complaints only. Model years 2013 and newer are tagged in full; 2012 in part (see tagged_share); earlier model years have no tags. NHTSA's own flags remain separate in the complaints block.
Recalls
See new recalls and investigations this week.
3 recalls.
Date: 2026-03-27. Systems: WHEELS.
Defect: Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2025 G580 vehicles. The incorrect wheel bolts may have been installed during vehicle manufacturing.
Consequence: Incorrect wheel bolts can allow a wheel to loosen or detach from the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the wheel bolts, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2026040008. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 2, 2026.
Do not drive: No. Park outside: No.
Date: 2025-10-17. Systems: FORWARD COLLISION AVOIDANCE.
Defect: Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2025 AMG G63 and G 580 vehicles. The front short-range radar sensor printed circuit board may fail and result in a loss of automatic emergency braking and other driver assistance features, including the active brake assist, lane keeping assist, and Distronic cruise control.
Consequence: An automatic emergency braking system that does not function as intended can increase the risk of a crash.
Remedy: Dealers will replace the short-range sensor, free of charge. Owner notification letters were mailed November 26, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2025110002. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 24, 2025.
Do not drive: No. Park outside: No.
Date: 2025-04-17. Systems: ELECTRONIC STABILITY CONTROL (ESC).
Defect: Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2025 G 550, G 580, and AMG G 63 vehicles. The vehicle's electronic stability program (ESP) may display an incorrect warning light during an ESP system failure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems," and 101, "Control and Displays."
Consequence: An incorrectly displayed warning light can fail to alert the driver to critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the ESP control unit software, free of charge. Owner notification letters are expected to be mailed June 17, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2025050002.
Do not drive: No. Park outside: No.
Manufacturer communications
50 manufacturer communications.
Communications by system| System | Count |
|---|
| ELECTRICAL SYSTEM | 27 |
|---|
| STRUCTURE | 5 |
|---|
| EXTERIOR LIGHTING | 4 |
|---|
| VISIBILITY/WIPER | 4 |
|---|
| UNKNOWN OR OTHER | 3 |
|---|
| ENGINE | 2 |
|---|
| FORWARD COLLISION AVOIDANCE | 2 |
|---|
| POWER TRAIN | 2 |
|---|
11038186
Date: 2026-09-22. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES.
Complaint Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is similar to a tire or wheel vibration, it is usually readily noticeable that it is distinctly different if it happens at all times or only while braking. Cause Although the cause of the vibra
11037432
Date: 2026-09-21. Type: Other. Systems: ELECTRICAL SYSTEM.
Tech. Awareness: G580e 465.600/465.601 - ISU For Model G580e 465.600/465.601 - Please be aware that initial start up of N147/10n1, N147/10n2, N147/11n1, N147/11n2 without HW replacement may result in HV battery warning and/or limp mode. In the event this occurs, please generate an ID1 Support Packag
11037243
Date: 2026-09-01. Type: Service Bulletin/Repair Instructions. Systems: VISIBILITY/WIPER.
Cause Internal failure of the scroll wheel within the AC compressor. Remedy Check the compressor's index and part number Figure 1 against Table 1. If listed please perform the following: 1. Replace the compressor, drier, and expansion valve using the applicable WIS instructions. 2. Flush the system
11036607
Date: 2026-08-26. Type: Service Bulletin/Repair Instructions. Systems: BACK OVER PREVENTION, FORWARD COLLISION AVOIDANCE.
Complaint Consistently reproducible erroneous parktronic warnings from front with every key cycle. Cause The parking sensors are detecting the front brush guard. Remedy Complaint must be consistently reproducible and can occur multiple times a key cycle without obvious cause. NOTE: The parking syste
11036101
Date: 2026-08-06. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Complaint Clanking noise from the area of the speakers in the doors. Cause Under analysis. Remedy To narrow down the cause, first of all remove the door trim. a ? If the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary
11035005
Date: 2026-07-14. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
Single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). The noise is heard once in each instance when changing direction of travel. Note: Sound file in attachment Cause If the complaint is eliminated by experimentally loosening the outboard collar n
11034506
Date: 2026-07-02. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE.
Complaint CEL light on with no drivability concerns. Cause Signal timing error. Remedy 167: SW has been released. Update the FSAM to the latest SW version. 465, 290, 118, 243, 247: Software is still in development. This fault code does not cause a drivability concern and will clear itself within 2-3
11034538
Date: 2026-07-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Complaint 1. "Perform vehicle handover" in the workshop menu to start the maintenance computer for service A/B cannot be carried out. 2. Service confirmation is not possible because "Perform vehicle handover" is displayed. This cannot be carried out. 3. The service display in the instrument cluster
11033185
Date: 2026-05-26. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Complaint After successful commissioning of the HERMES control unit (N112/9) with XENTRY Diagnosis DVD 03/2026, the message "SOS - service not activated" appears on the instrument cluster. In addition, the following two conditions are also met: a ? HERMES (N112/9) control unit: event code B15CE00 is
11031558
Date: 2026-04-24. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Complaint The intent of this document is to provide workshops with helpful technical reference language. a ? Commonly used acronyms in LI's and TIPS cases. a ? Control unit names, numbers, and how to identify. a ? Network/wiring architecture groups to baumuster quick reference. a ? Platform to baumu