NHTSA lists 119 complaints for the 2000 Saab 9-5, 3 of them mention a crash and 5 mention a fire. 4 complaints mention an injury, with 4 injuries and 0 deaths reported.
Data build 2026-10-07.
NHTSA lists this vehicle as SAAB 9-5.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
3 recalls.
Date: 2005-09-14. Systems: ELECTRICAL SYSTEM.
Defect: CERTAIN PASSENGER VEHICLES EQUIPPED WITH B205/B235 4-CYLINDER GASOLINE ENGINES AND B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS. (excerpt)
Consequence: OVERHEATING OF THE IGBT OCCURS MOST OFTEN AT ENGINE START-UP, BUT IT MAY ALSO OCCUR WHILE THE ENGINE IS RUNNING. ENGINE STALLING MAY OCCUR, WHICH COULD RESULT IN A CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT TO SEE WHAT VERSION IDM IS IN THE VEHICLE AND REPLACE THE IDM IF IT IS A VERSION BUILT PRIOR TO THE INTRODUCTION OF QP3. AN INTERIM LETTER WILL BE MAILED TO OWNERS IN OCTOBER 2005, INFORMING THEM OF THE CONDITION. PARTS ARE NOW AVAILABLE AND OWNERS WILL BE NOTIFIED TO BRING THEIR VEHICLES IN TO THE DEALERS TO HAVE THE IDM REPLACED BY LETTER DATED MARCH 13, 2006. OWNERS MAY (excerpt)
Do not drive: No. Park outside: No.
Date: 2003-01-13. Systems: WHEELS.
Defect: ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COU (excerpt)
Consequence: THESE FRACTURES WOULD RESULT IN WHEEL BOLT BREAKAGE, ALLOWING THE WHEEL TO DETACH FROM THE WHEEL HUB, INCREASING THE RISK OF A CRASH. (excerpt)
Remedy: OWNERS WILL BE CONTACTED BY MAIL AND ASKED WHETHER THEY CHANGE BETWEEN STEEL AND ALLOY WHEELS. IF THEY DO ENGAGE IN THIS PRACTICE, THEY WILL BE INSTRUCTED TO BRING THEIR CARS TO AN AUTHORIZED DEALER. THE DEALER WILL REMOVE THE WHEELS, CLEAN ANY CONTAMINATION FROM THE WHEEL AND WHEEL HUB, AND REPLACE THE WHEELS USING NEW IMPROVED BOLTS WITH ATTACHED WASHERS. OWNER NOTIFICATION BEGAN MARCH 31, 20 (excerpt)
Do not drive: No. Park outside: No.
Date: 2001-05-18. Systems: AIR BAGS.
Defect: VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG ALERT LABELS MAY NOT BE PERMANENTLY AFFIXED AS REQUIRED BY THIS STANDARD.
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.
Remedy: DEALERS WILL CLEAN THE SUNVISOR SURFACE AND APPLY A NEW AIR BAG ALERT LABEL ON BOTH SUNVISORS. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.
Do not drive: No. Park outside: No.
Investigations
1 investigations; 0 open.
PE05017
Opened: 2005-04-07. Closed: 2005-09-23.
ENGINE STALL/ ENGINE COMPARTMENT FIRES
ODI OPENED PE05-017 BASED ON 35 REPORTS OF ALLEGED ENGINE STALLING DUE TO THE FAILURE OF THE IDM CASSETTE ON THE SUBJECT VEHICLES.ALL COMPLAINANTS REPORTED THAT THE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING AND MOST REPORTED THAT THE VEHICLE WOULD NOT RESTART.IN 3 INCIDENTS, THE COMPLAINANTS REPORTED SMOKE AND/OR FIRE RESULTED FROM THE IDM FAILURE.DURING PE05-017, ADDITIONAL FAILURE DATA WAS IDENT
Systems: ELECTRICAL SYSTEM.
Linked campaign numbers: 05V399000, 06V410000.
Manufacturer communications
58 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 19 |
|---|
| ELECTRICAL SYSTEM | 12 |
|---|
| ENGINE AND ENGINE COOLING | 12 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 5 |
|---|
| UNKNOWN OR OTHER | 5 |
|---|
| WHEELS | 5 |
|---|
| ENGINE | 3 |
|---|
| SEATS | 2 |
|---|
11006621
Date: 2024-08-26. Type: Service Campaign. Systems: ELECTRICAL SYSTEM.
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is com
11004557
Date: 2024-06-17. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
11002312
Date: 2024-06-06. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
10251890
Date: 2024-03-13. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
10250775
Date: 2024-02-22. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
10244274
Date: 2023-10-06. Type: Service Bulletin/Repair Instructions. Systems: WHEELS.
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
10242262
Date: 2023-08-24. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
10235799
Date: 2023-04-27. Type: Service Bulletin/Repair Instructions. Systems: WHEELS.
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
10234110
Date: 2023-03-17. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
10232287
Date: 2023-02-21. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.