Defect: ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE FASTENERS HOLDING THE FUEL TANK MOUNTING STRAPS MAY NOT HAVE BEEN PROPERLY TIGHTENED, ALLOWING THE POSSIBILITY FOR THE FUEL TANK TO LOOSEN AND FALL.
Consequence: IF THE FUEL TANK FALLS, THERE IS THE POTENTIAL FOR THE TANK TO IGNITE, RESULTING IN PERSONAL INJURY, VEHICLE AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND PROPERLY TIGHTEN THE FASTENERS TO THE FUEL TANK STRAPS. THE RECALL BEGAN ON OCTOBER 15, 2005. OWNERS MAY CONTACT WINNEBAGO AT 614-585-6939.
Date: 2004-10-20. Systems: ENGINE AND ENGINE COOLING.
Defect: ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
Defect: ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH GAS ENGINES, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR WINNEBAGO AT 641-585-3535.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
7 manufacturer communications.
Communications by system
System
Count
EQUIPMENT
4
UNKNOWN OR OTHER
2
STRUCTURE
1
10252834
Date: 2024-04-05. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Service Bulletin sent to dealers advising of the required legal verbiage each RO should document.
10251128
Date: 2024-02-23. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
Service Bulletin sent to all Winnebago dealers. Bulletin outlines the characteristics of new roof sealant being used.
10226724
Date: 2022-09-19. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Service Bulletin sent to all Winnebago dealers. Bulletin advises of a manufacturing change to the shower surround sealant process for all units.
10213593
Date: 2022-05-31. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Service Bulletin sent to all dealers. This bulletin advises dealers they no longer need to email Winnebago the signed Vehicle Registration Form, but they should retain a copy for their records.
10199382
Date: 2021-07-14. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Service Bulletin to dealers reminding them to understand their state's Lemon Law and to comply with Winnebago Motorhome mandates outlined in the Policy & Procedure Manual.
10199381
Date: 2021-07-01. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Service Bulletin to dealers advising them of part sales training opportunities.
10199380
Date: 2021-03-26. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
General Parts and Service Letter to dealers detailing the warranty part return procedure.
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.