NHTSA lists 1 complaints for the 2000 Workhorse W20, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-07.
NHTSA lists this vehicle as WORKHORSE W20.
At a glance
Complaints
1
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
1
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
10,235
Investigations
2
Open investigations
0
Manufacturer communications
0
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
PARKING BRAKE
1
100.0%
Top subsystems
System
Subsystem
Complaints
PARKING BRAKE
DRIVELINE
1
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Date: 2004-02-18. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: ON CERTAIN MOTORHOME CHASSIS EQUIPPED WITH BOSCH ZOPS, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
Consequence: A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT, REPAIR AND REPLACE ACCORDING TO THE PROCEDURE DEVELOPED BY BOSCH (SEE CAMPAIGN 03E064000). THE RECALL BEGAN ON AUGUST 1, 2004. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773.
Do not drive: No. Park outside: No.
Investigations
2 investigations; 0 open.
EA07016
Opened: 2007-11-16. Closed: 2009-08-19.
OVERHEATING DISC BRAKE CALIPER
THE EA WAS OPENED TO GAIN A TECHNICAL UNDERSTANDING OF THE CAUSES FOR ONE OR MORE DISC BRAKE CALIPERS ON A SUBJECT VEHICLE TO SUFFER SEVERE OVERHEATING. THE OVERHEATING CAUSED BRAKE DRAG, MELTING ABS SENSORS, SMOKING, BRAKE LINING FIRES, AND IN SOME CASES BOILING BRAKE FLUID RESULTING IN DIMINISHED STOPPING CAPABILITY.BASED ON TESTING, WARRANTY AND COMPLAINT DATA ANALYSIS, FIELD TRIPS AND INTERVIE
ON JUNE 25, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED OVERHEATING DISC BRAKE CALIPERS AND POOR BRAKE PERFORMANCE IN MODEL YEAR (MY) 2000-2005 WORKHORSE CHASSIS RECREATIONAL VEHICLES.CURRENTLY ODI IS AWARE OF 651 SPECIFIC COMPLAINTS ON THE SUBJECT VEHICLES (ODI AND WORKHORSE COMPLAINT POPULATION).ODI ANALYSIS OF THE WARRANTY AND COMPLAINT
Systems: SERVICE BRAKES, HYDRAULIC.
Linked campaign numbers: None listed.
Manufacturer communications
0 manufacturer communications.
Communications by system
System
Count
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.