NHTSA lists 2 complaints for the 2007 Fleetwood Bounder Diesel, 0 of them mention a crash and 0 mention a fire. 0 complaints mention an injury, with 0 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as FLEETWOOD BOUNDER DIESEL.
At a glance
Complaints
2
With crash
0
With fire
0
With injury (complaints)
0
Injuries
0
Deaths
0
Recalls
2
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
18,000
Investigations
0
Open investigations
0
Manufacturer communications
2
Complaints per 100k sold unavailable. No sales source is available for this record.
Where the complaints are
Top systems
System
Complaints
Share of this vehicle's complaints
ELECTRICAL SYSTEM
1
50.0%
VISIBILITY
1
50.0%
Top subsystems
System
Subsystem
Complaints
ELECTRICAL SYSTEM
12V/24V/48V BATTERY
1
One complaint can name several systems, so shares can add to more than 100 percent.
Model-generated complaint tags: This model year has not been tagged.
Defect: FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Consequence: THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Remedy: DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Defect: FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
2 manufacturer communications.
Communications by system
System
Count
ELECTRICAL SYSTEM
1
SERVICE BRAKES, ELECTRIC
1
10022565
Date: 2009-02-01. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, ELECTRIC.
ACCUMULATION OF MOISTURE INSIDE THE ELECTRIC LEVELER MOTOR BRAKE BOOT. THIS CAUSES CORROSION OF THE LEVELER BRAKE AND SUBSEQUENT SEIZURE OF THE LEVELER MOTOR. FLEETWOOD. *KB UPDATED 7/6/09. *PE
10022825
Date: 2008-02-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
ELECTRIC LEVELERS MAY FAIL TO OPERATE PROPERLY DUE TO AN OPEN CIRCUIT IN THE SENSOR HARNESS, OR A CONTROL MODULE THAT DOES NOT FUNCTION PER DESIGN. *KB UPDATED 6/14/10. *PE
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.