The Used Car Index

2006 Ford Freestyle problems

NHTSA lists 1,300 complaints for the 2006 Ford Freestyle, 42 of them mention a crash and 10 mention a fire. 10 complaints mention an injury, with 18 injuries and 0 deaths reported.

Data build 2026-10-08.

NHTSA lists this vehicle as FORD FREESTYLE.

At a glance

Complaints
1,300
With crash
42
With fire
10
With injury (complaints)
10
Injuries
18
Deaths
0
Recalls
1
Do not drive recalls
0
Park outside recalls
0
Recall potential units (maximum)
139,537
Investigations
1
Open investigations
0
Manufacturer communications
23

Complaints per 100k sold unavailable. No sales source is available for this record.

Where the complaints are

Top systems
SystemComplaintsShare of this vehicle's complaints
VEHICLE SPEED CONTROL60246.3%
POWER TRAIN48437.2%
ENGINE AND ENGINE COOLING14411.1%
ENGINE1148.8%
FUEL SYSTEM, GASOLINE856.5%
ELECTRICAL SYSTEM846.5%
UNKNOWN OR OTHER745.7%
FUEL/PROPULSION SYSTEM534.1%
SERVICE BRAKES, HYDRAULIC493.8%
STRUCTURE282.2%
Top subsystems
SystemSubsystemComplaints
POWER TRAINAUTOMATIC TRANSMISSION127
ENGINE AND ENGINE COOLINGENGINE44
STRUCTUREBODY20
SERVICE BRAKES, HYDRAULICFOUNDATION COMPONENTS11
ENGINE AND ENGINE COOLINGCOOLING SYSTEM8
AIR BAGSFRONTAL4
ENGINE AND ENGINE COOLINGEXHAUST SYSTEM4
EQUIPMENTAPPLIANCE4
POWER TRAINDRIVELINE4
ELECTRICAL SYSTEMINSTRUMENT CLUSTER/PANEL3

One complaint can name several systems, so shares can add to more than 100 percent.

Model-generated complaint tags: This model year has not been tagged.

Recalls

See new recalls and investigations this week.

1 recalls.

06V383000

Date: 2006-10-05. Systems: LATCHES/LOCKS/LINKAGES.

Defect: ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMIN (excerpt)

Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING. (excerpt)

Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (excerpt)

Do not drive: No. Park outside: No.

Investigations

1 investigations; 0 open.

PE11018

Opened: 2011-05-11. Closed: 2013-02-07.

Idle instability

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start

Systems: VEHICLE SPEED CONTROL.

Linked campaign numbers: None listed.

Manufacturer communications

23 manufacturer communications.

Communications by system
SystemCount
ELECTRICAL SYSTEM6
ENGINE AND ENGINE COOLING4
POWER TRAIN3
ENGINE2
SEATS2
FUEL SYSTEM, GASOLINE1
SERVICE BRAKES, AIR1
SERVICE BRAKES, HYDRAULIC1

11000557

Date: 2024-05-24. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.

MotorcraftA? Continuously Variable Chain-Type Transmission Fluid (XT-7-QCFT in non-Canadian markets, CXT-7-LCF12 in Canada) is no longer manufactured and will only be available until inventory depletes. The recommended replacement fluids are Phillips 66 VersaTransA? CVT Plus Fluid or Kendall VersaTr

10109070

Date: 2016-09-21. Type: Service Bulletin/Repair Instructions. Systems: ENGINE, ENGINE AND ENGINE COOLING.

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to

10051815

Date: 2012-11-29. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.

FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP MAY ILLUMINATE. MODELS 2005-07 FREESTYLE, 500, MONTEGO.

10023294

Date: 2007-11-28. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.

FORD MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. *NJ UPDATED 1/25/08. *NJ

10022241

Date: 2007-04-01. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.

MIL WITH DTC P0106 AND/OR P0109. *KB

10021061

Date: 2006-08-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.

BATTERY LIGHT ILLUMINATED. *KB

10019377

Date: 2006-01-01. Type: Service Bulletin/Repair Instructions. Systems: SEATS.

HEATED SEATS INOPERATIVE. *TT

10019950

Date: 2006-01-01. Type: Service Bulletin/Repair Instructions. Systems: SEATS.

SECOND ROW SEAT RECLINE CONCERN. *TT

10019951

Date: 2006-01-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.

INTERMITTENT INSTRUMENT CLUSTER GAUGE SWEEP/RESET - MULTIPLE WARNING LIGHTS ON - REVERSE LIGHTS ON - VEHICLES BUILT BEFORE 2/17/2006. *TT

10020134

Date: 2006-01-01. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.

CONTINUOUSLY VARIABLE TRANSAXLE (CVT) NOISE DIAGNOSIS. *TT

Notes on this record

  • Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
  • System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
  • Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
  • A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.

Other names NHTSA uses

None listed.

Matched NHTSA models

Matched labels and complaints
NHTSA model labelComplaints
FREESTYLE1,300

Same model, other years

All model years | All Ford models

Other Ford models, 2006

Sources

Get this record as JSON

The free rate-limited demo needs no key.

curl "https://api.theusedcarindex.com/v1/demo/vehicle_risk?make=Ford&model=Freestyle&year=2006"

Paid endpoint: https://api.theusedcarindex.com/v1/vehicle_risk. MCP endpoint: https://api.theusedcarindex.com/mcp.