NHTSA lists 176 complaints for the 2004 Kia Sedona, 10 of them mention a crash and 14 mention a fire. 8 complaints mention an injury, with 25 injuries and 2 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as KIA SEDONA.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
2 recalls.
Date: 2005-07-20. Systems: VEHICLE SPEED CONTROL.
Defect: ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Do not drive: No. Park outside: No.
Date: 2005-05-19. Systems: WHEELS.
Defect: ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Do not drive: No. Park outside: No.
Investigations
3 investigations; 0 open.
EA08017
Opened: 2008-08-28. Closed: 2009-07-01.
STEERING INTERMEDIATE SHAFT BINDING
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEAR
Systems: STEERING.
Linked campaign numbers: None listed.
PE08033
Opened: 2008-04-28. Closed: 2008-08-28.
STEERING BINDING
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICL
Systems: STEERING.
Linked campaign numbers: None listed.
PE04067
Opened: 2004-09-24. Closed: 2005-01-27.
THROTTLE CABLE BINDING
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE
Systems: VEHICLE SPEED CONTROL.
Linked campaign numbers: 05V013000, 05V329000.
Manufacturer communications
18 manufacturer communications.
Communications by system| System | Count |
|---|
| ENGINE AND ENGINE COOLING | 4 |
|---|
| ELECTRICAL SYSTEM | 3 |
|---|
| EQUIPMENT | 3 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 3 |
|---|
| STRUCTURE | 3 |
|---|
| EXTERIOR LIGHTING | 2 |
|---|
| SUSPENSION | 2 |
|---|
| FUEL SYSTEM, GASOLINE | 1 |
|---|
10201529
Date: 2021-09-13. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING, STRUCTURE.
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models tha
10133170
Date: 2018-03-02. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
10109812
Date: 2017-01-18. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY.
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washe
10109777
Date: 2016-11-04. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT ADAPTIVE/MOBILITY, LATCHES/LOCKS/LINKAGES.
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other
10183431
Date: 2016-04-04. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY.
TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cab
10091489
Date: 2013-12-06. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
TSB: AUTOMATIC TRANSMISSION FLUID APPLICATION GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATING TO THE CORRECT AUTOMATIC TRANSMISSION FLUIDS THAT ARE REQUIRED FOR EACH KIA MODEL. REFER TO THE SHOP MANUAL ON KGIS FOR THE SPECIFIC KIA MODEL, THEN REFERENCE THE AUTOMATIC TRANSAXLE SYSTEM/ REPAIR PROC
10034246
Date: 2010-05-01. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
KIA: INTERMITTENT MIL ON WITH NO FAULT CODE STORED; INFORMATION ABOUT DTC P1330. PROVIDES INFORMATION RELATING TO CERTAIN VEHICLES. IN AFFECTED VEHICLES AN INTERMITTENT SHORT TO GROUND IN A CIRCUIT ONLY INTENDED FOR TESTING PURPOSES MAY CAUSE THE MIL TO ILLUMINATE AND A DTC P1330 (SPARK TIMING ADJ
10033464
Date: 2009-11-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING.
KIA: ECM UPGRADE WITH TP SENSOR REPLACEMENT-MIL ON WITH DTC P2135/P0638. INFORMATION RELATED TO ECM SOFTWARE AND TP SENSOR UPGRADE ON SOME VEHICLES WITH 2.7L ENGINES WHICH MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH THE ELECTRONIC THROTTLE CONTROL (ETC) SYSTEM RELATED DTC P2
10031947
Date: 2009-09-01. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, STRUCTURE.
KIA: POWER SLIDING DOOR REMOE CONTROLLER MOTOR REPLACEMENT. ON SOME VEHICLES, A POWER SLIDING DOOR (PSD) MAY NOT OPEN WHEN USING AN OVERHEAD CONSOLE SWITCH, B PILLAR SWITCH OR REMOTE CONTROL BUTTON. *PE
10027724
Date: 2008-10-01. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
KIA: INCREASED STEERING EFFORT. IN AREAS WHERE HEAVY ROAD SALT USE OCCURS, INCREASED STEERING EFFORT AND NOISE (FROM STEERING INTERMEDIATE SHAFT) FOR SOME SEDONA. *PE