NHTSA lists 464 complaints for the 2000 Mercury Sable, 34 of them mention a crash and 8 mention a fire. 16 complaints mention an injury, with 20 injuries and 0 deaths reported.
Data build 2026-10-08.
NHTSA lists this vehicle as MERCURY SABLE.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
7 recalls.
Date: 2004-07-15. Systems: SUSPENSION.
Defect: ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSIO (excerpt)
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH. (excerpt)
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL (excerpt)
Do not drive: No. Park outside: No.
Date: 2004-03-02. Systems: EXTERIOR LIGHTING.
Defect: CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Do not drive: No. Park outside: No.
Date: 2002-10-02. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM. (excerpt)
Consequence: THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION. (excerpt)
Remedy: OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RE (excerpt)
Do not drive: No. Park outside: No.
Date: 2001-08-08. Systems: VISIBILITY.
Defect: VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST L (excerpt)
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH. (excerpt)
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332. (excerpt)
Do not drive: No. Park outside: No.
Date: 2001-03-12. Systems: EXTERIOR LIGHTING.
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.
Consequence: A SHORT CIRCUIT COULD LEAD TO EITHER THE BRAKE LAMPS STAYING ON, OR TO A LOSS OF BRAKE LAMP FUNCTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Do not drive: No. Park outside: No.
Date: 2001-03-12. Systems: EXTERIOR LIGHTING.
Defect: VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.
Consequence: THIS WOULD CAUSE DIFFICULTY FOR THE DRIVER TO ACTIVATE THE HEADLAMPS, WHICH COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH KNOB. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Do not drive: No. Park outside: No.
Date: 2000-08-24. Systems: EQUIPMENT.
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE "VEHICLE CAPACITY WEIGHT" AND "DESIGNATED SEATING CAPACITY" INFORMATION WAS NOT PRINTED ON THE SAFETY CERTIFICATION LABELS AFFIXED TO THESE VEHICLES. ON AFFECTED SABLE SEDAN VEHICLES, THE "VEHICLES CAPACITY WEIGHT" (AND ALSO THE LUGGAGE LOAD) INFORMATION PRINTED ON THIS LABEL IS INCORRECT - SABLE WAGON LUGGAGE LOAD WAS INCORRECTLY USED FOR THE SABL (excerpt)
Consequence: EXCESSIVE LOADING CAN CAUSE TIRE AND VEHICLE DAMAGE THAT COULD RESULT IN A CRASH. (excerpt)
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENTAL LABEL WITH THE CORRECT INFORMATION, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL ADJACENT TO THE VEHICLE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN OCTOBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-367 (excerpt)
Do not drive: No. Park outside: No.
Investigations
9 investigations; 0 open.
PE12033
Opened: 2012-10-24. Closed: 2013-06-26.
Speed control cable damage
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to dam
Systems: VEHICLE SPEED CONTROL.
Linked campaign numbers: None listed.
EA06002
Opened: 2006-01-24. Closed: 2007-02-05.
REAR COIL SPRING FRACTURE
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CA
Systems: SUSPENSION.
Linked campaign numbers: None listed.
PE05054
Opened: 2005-09-27. Closed: 2006-01-24.
REAR COIL SPRING FRACTURE
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINA
Systems: SUSPENSION.
Linked campaign numbers: None listed.
PE04044
Opened: 2004-05-24. Closed: 2004-08-16.
FRONT SUSPENSION COIL SPRING FRACTURE
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCA
Systems: SUSPENSION.
Linked campaign numbers: 04V332000.
RP03001
Opened: 2003-10-31. Closed: 2004-03-23.
BRAKE/ACCELERATOR PEDAL APPLICATION
MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE AND ACCELERATOR PEDALS TO INSURE THAT THE SEPARAT
Systems: SERVICE BRAKES, HYDRAULIC.
Linked campaign numbers: None listed.
RQ03008
Opened: 2003-10-23. Closed: 2004-03-05.
BRAKE LIGHT SWITCH FAILURE
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEH
Systems: EXTERIOR LIGHTING.
Linked campaign numbers: 04V106000.
EA03010
Opened: 2003-07-02. Closed: 2004-06-23.
FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH
THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED
Systems: AIR BAGS.
Linked campaign numbers: None listed.
PE03002
Opened: 2003-01-06. Closed: 2003-07-02.
FRONTAL AIR BAG NON-DEPLOYMENT IN CRASH
FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE SINGLE ODI REPORT LISTED IN THE REPORT SUMMARY IS NHTSA'S SPECIAL CRASH INVESTIGATION'S CASE NO.
Systems: AIR BAGS.
Linked campaign numbers: None listed.
PE02035
Opened: 2002-03-15. Closed: 2002-10-22.
BRAKE/ACCEL PEDAL SEPARATION
Summary unavailable
Systems: SERVICE BRAKES, HYDRAULIC.
Linked campaign numbers: 02V266000.
Manufacturer communications
170 manufacturer communications.
Communications by system| System | Count |
|---|
| POWER TRAIN | 44 |
|---|
| ENGINE AND ENGINE COOLING | 37 |
|---|
| ELECTRICAL SYSTEM | 15 |
|---|
| EQUIPMENT | 13 |
|---|
| VISIBILITY | 13 |
|---|
| UNKNOWN OR OTHER | 9 |
|---|
| SUSPENSION | 8 |
|---|
| AIR BAGS | 7 |
|---|
10177863
Date: 2020-07-13. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is
10155551
Date: 2019-02-07. Type: Service Bulletin/Repair Instructions. Systems: STRUCTURE.
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
10156863
Date: 2019-02-07. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, STRUCTURE.
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
10183769
Date: 2016-04-21. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
For 1999-2001 Taurus or Sable vehicles Safety Recall 04S17 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the front coil springs could potentially fracture. A fractured front coil spring could move past the spring seat and contact a front tire. I
10205033
Date: 2016-04-21. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
Safety recall 04S17 - Front coil springs - requests for recall service action
10058102
Date: 2014-09-09. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
MERCURY/FORD: SAFETY RECALL REGARDING FRONT COIL SPRINGS CAN FRACTURE ON VEHICLES OPERATING FOR EXTENDED PERIODS IN HIGH CORROSION AREAS. MODEL 1999-01 TAURUS, SABLE. *PE
10056656
Date: 2014-08-11. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
MERCURY/FORD: FRONT COIL SPRINGS CAN FRACTURE, AFTER OPERATING, FOR AN EXTENDED PERIOD OF TIME, IN HIGH CORROSION AREAS, MOVE MOVE PAST SPRING SEAT AND CONTACT RUPTURE FRONT TIRE, RESULTING RAPID AIR LOSS. MODEL 1999-2001 TAURUS, SABLE. *PE
10052600
Date: 2013-06-21. Type: Service Bulletin/Repair Instructions. Systems: VEHICLE SPEED CONTROL.
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. MODELS 2000-2003 TAURUS, SABLE. *PE
10018745
Date: 2005-11-14. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT
10018746
Date: 2005-11-14. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT