Defect: ON CERTAIN BUSES BUILT ON PREVOST CHASSIS AND EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
Consequence: THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.
Remedy: VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR AMERICAN CARRIAGE AT 1-800-631-0951.
Defect: ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE POWER STEERING HOSE CAN RUB IN THE ENGINE COMPARTMENT AND IN THE SPARE TIRE COMPARTMENT WHICH WILL CAUSE A POWER STEERING HOSE BREAK DOWN.
Consequence: LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.
Remedy: DEALERS WILL INSPECT THE HOSES AND REPLACE THEM IF THERE IS EVIDENCE OF WEAR FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2005. OWNERS MAY CONTACT PREVOST AT 418-831-5432.
Defect: ON CERTAIN MOTOR COACHES AND MOTOR HOMES, THE STEERING COLUMNS MAY BE MISSING THE LOWER BOLT AND NUT. A REPLACEMENT BOLT AND NUT WAS INSTALLED TO CORRECT THIS SITUATION ON THE PRODUCTION LINE. IF A REPLACEMENT BOLT HAS BEEN USED AND NOT TIGHTENED PROPERLY, THE COLUMN MAY COME OUT OF THE INPUT SHAFT WHEN THE STEERING COLUMN ADJUSTMENT MECHANISM IS USED.
Consequence: IN SUCH A CASE, A LOSS OF STEERING WOULD OCCUR.
Remedy: DEALERS WILL VERIFY THE SIZE OF THE BOLT AND NUT AND REPLACE THEM IF NEEDED. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PREVOST AT 1-418-831-5432.
Do not drive: No. Park outside: No.
Investigations
1 investigations; 0 open.
PE05012
Opened: 2005-02-28. Closed: 2005-04-14.
POWER STEERING HOSE LEAKAGE
THIS INVESTIGATION WAS OPENED AS THE RESULT OF ODI'SREVIEW OF PREVOST SERVICE BULLETIN, WB04-10,ISSUED IN DECEMBER 2004 AND TITLED INSPECTION AND REPLACEMENT OF POWER STEERING PRESSURE HOSE.THE BULLETIN ADDRESSED THE POSSIBILITY THAT POWER STEERING ASSIST COULD BE LOST DUE TO A POWER STEERING PRESSURE HOSE FAILURE.THE BULLETIN INSTRUCTED THE DEALER TO INSPECT, REPLACE, AND REPOSITIONED THE HOSES T
Date: 2024-06-04. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
Sway bar collars improvement. Revision A : Add front sway bar support replacement and change bolts lenght.
10248275
Date: 2023-12-14. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
SWAY BAR COLLARS IMPROVEMENT
10240148
Date: 2023-07-04. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
H3 LAVATORY FAN RETROFIT KIT
10231093
Date: 2023-01-16. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
STEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139
10228667
Date: 2022-12-07. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.
Air Tanks Draining Sequence. Revision: B - General Update
10226928
Date: 2022-11-17. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.
Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location.
10226927
Date: 2022-11-02. Type: Service Bulletin/Repair Instructions. Systems: SERVICE BRAKES, AIR.
Air Tanks Draining Sequence
10226925
Date: 2022-11-01. Type: Service Bulletin/Repair Instructions. Systems: EXTERIOR LIGHTING, VISIBILITY.
Halogen to LED fog light replacement kit. Revision: C - Advanced kits canceled
10214935
Date: 2022-06-13. Type: Service Bulletin/Repair Instructions. Systems: VISIBILITY.
CENTRAL HVAC MERV FILTERS INSTALLATION
10199002
Date: 2021-06-15. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.