NHTSA lists 430 complaints for the 2001 Volkswagen Passat, 14 of them mention a crash and 14 mention a fire. 11 complaints mention an injury, with 11 injuries and 0 deaths reported.
Data build 2026-10-09.
NHTSA lists this vehicle as VOLKSWAGEN PASSAT.
Model-generated complaint tags: This model year has not been tagged.
Recalls
See new recalls and investigations this week.
3 recalls.
Date: 2008-04-07. Systems: FUEL SYSTEM, GASOLINE.
Defect: VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) T (excerpt)
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE. (excerpt)
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. T (excerpt)
Do not drive: No. Park outside: No.
Date: 2002-01-25. Systems: FUEL SYSTEM, GASOLINE.
Defect: ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES. (excerpt)
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE. (excerpt)
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE (excerpt)
Do not drive: No. Park outside: No.
Date: 2001-05-03. Systems: FUEL SYSTEM, GASOLINE.
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY. (excerpt)
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS. (excerpt)
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NO (excerpt)
Do not drive: No. Park outside: No.
Investigations
7 investigations; 0 open.
EA11002
Opened: 2011-01-26. Closed: 2012-02-17.
Engine Compartment Fire
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fir
Systems: ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING.
Linked campaign numbers: None listed.
PE08008
Opened: 2008-01-31. Closed: 2008-05-30.
FUEL TANK LEAK
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED
Systems: FUEL SYSTEM, GASOLINE, FUEL SYSTEM, OTHER.
Linked campaign numbers: 08V156000, 08V157000.
EA07014
Opened: 2007-09-28. Closed: 2008-07-07.
PASSENGER ENGINE COMPARTMENT FIRES
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL A
Systems: ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING.
Linked campaign numbers: 08V156000.
PE07024
Opened: 2007-05-10. Closed: 2007-09-28.
PASSENGER/ENGINE COMPARTMENT FIRES
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATI
Systems: ELECTRICAL SYSTEM.
Linked campaign numbers: None listed.
DP05004
Opened: 2005-08-11. Closed: 2005-12-08.
ENGINE STALLING
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW
Systems: ELECTRICAL SYSTEM.
Linked campaign numbers: None listed.
EA03020
Opened: 2003-10-07. Closed: 2004-04-23.
PASSENGER AIR BAG LID FAILURE
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSI
Systems: AIR BAGS.
Linked campaign numbers: None listed.
PE03021
Opened: 2003-05-23. Closed: 2003-10-07.
PASSENGER SIR DOOR MOUNTING STUD FAILURE
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING
Systems: AIR BAGS.
Linked campaign numbers: None listed.
Manufacturer communications
207 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 67 |
|---|
| ELECTRICAL SYSTEM | 43 |
|---|
| ENGINE AND ENGINE COOLING | 41 |
|---|
| STRUCTURE | 25 |
|---|
| VISIBILITY | 19 |
|---|
| EXTERIOR LIGHTING | 14 |
|---|
| ENGINE | 11 |
|---|
| WHEELS | 9 |
|---|
10241177
Date: 2023-08-21. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Update to Volkswagen engine oil standards
10237427
Date: 2023-05-30. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Volkswagen Engine oil quality standards, update to attachments.
10235138
Date: 2023-04-24. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Engine oil quality standards, update to attachments.
10228180
Date: 2022-12-12. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Update model year applicability to include 2023.
10228178
Date: 2022-12-06. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.
10175799
Date: 2020-05-12. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Tool number added to table. Removal of Behr Flush Kit. VAS 6337/1A
10174476
Date: 2020-04-21. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
Updated to include additional models and model year applicability.
10161215
Date: 2019-06-12. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY.
Update vehicle metadata.
10159010
Date: 2019-03-27. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT.
The part number listed in the document is to be returned if it meets the criteria provided.
10159014
Date: 2019-03-22. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, EQUIPMENT.
Alternative method for radio code retrieval.