Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms. (excerpt)
Consequence: A loose steering arm can result in a loss of vehicle steering control, increasing the risk of a crash. (excerpt)
Remedy: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2607. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July (excerpt)
Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach. (excerpt)
Consequence: Wheel detachment can cause a loss of vehicle control or create a road hazard, increasing the risk of a crash or injury. (excerpt)
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary, free of charge. Owner notification letters were mailed June 15, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2606 (excerpt)
Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2026 VAH trucks. The passenger seat belt anchor may fail due to inadequate floor reinforcement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Consequence: A seat belt anchor that fails will not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will install a new weld nut and washer, free of charge. Owner notification letters were mailed December 16, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2510. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 10, 2025.
Do not drive: No. Park outside: No.
Investigations
0 investigations; 0 open.
Manufacturer communications
13 manufacturer communications.
Communications by system
System
Count
ELECTRICAL SYSTEM
6
ENGINE
4
SUSPENSION
2
AIR BAGS
1
POWER TRAIN
1
UNKNOWN OR OTHER
1
11037669
Date: 2026-09-21. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
Overheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area. The alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operat
11037659
Date: 2026-09-17. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, UNKNOWN OR OTHER.
This CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box due to misalignment during installation.
11037667
Date: 2026-09-14. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
The ELD connected to the RP1226 connector in the truck remains powered on always. As a result in the batteries being depleted within a very short amount of time (a few hours after the truck is shut down).
11034124
Date: 2026-06-22. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM, ENGINE.
The purpose of this CBR is to provide steps on how to correct a customer complaint of DTC P107B86 accompanied With intermittent loss of throttle.
11033149
Date: 2026-05-29. Type: Over The Air. Systems: AIR BAGS.
If you have received this document, it is because one or more of the following Faults has been active for at least 5 minutes and can potentially prevent the Supplemental Restraint System/Airbag Inflation System (SRS) from functioning properly in the event of a collision. Tech Tool will need to be us
11030470
Date: 2026-03-19. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
CBR - No Start Condition After Over the Air Programing - VECU5 No Start "Safe State"
11030472
Date: 2026-03-03. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
CBR - Z Spring Bracket Wear. Volvo Chassis
11028025
Date: 2026-01-09. Type: Service Bulletin/Repair Instructions. Systems: POWER TRAIN.
CBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit (TECU ) Air Ports And Control Housing.
11028007
Date: 2026-01-07. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
CBR - Volvo DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and US22+OBD23 (DOES NOT APPLY TO VN(4))
11026966
Date: 2025-12-04. Type: Service Bulletin/Repair Instructions. Systems: ENGINE.
CBR - 3 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between The Coolant Pump Housing And Oil Cooler Housing
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.