Date: 2025-11-06. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: General Motors, LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. These vehicles were remedied under NHTSA Recall 25V390 with a brake jumper wire harness that was assembled without protective tape. A wiring harness that is missing protective tape can allow the wires to become damaged. (excerpt)
Consequence: Damaged brake jumper wires can result in power brake assist failure, increasing the risk of a crash. (excerpt)
Remedy: Dealers will remove the installed wire harness, apply protective tape, and reinstall the wire harness, free of charge. Owner notification letters are planned to be mailed December 22, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N252531990. Vehicles in this recall were previously repaired under 25V390 and will need to have the new remedy (excerpt)
Date: 2025-06-12. Systems: SERVICE BRAKES, HYDRAULIC.
Defect: General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit. (excerpt)
Consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked. (excerpt)
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N242482680. Vehicles in this recall that were previously repaired u (excerpt)
Do not drive: No. Park outside: Yes.
Investigations
0 investigations; 0 open.
Manufacturer communications
504 manufacturer communications.
Communications by system
System
Count
EQUIPMENT
128
ENGINE AND ENGINE COOLING
124
ELECTRICAL SYSTEM
99
UNKNOWN OR OTHER
81
ENGINE
55
POWER TRAIN
43
WHEELS
38
FUEL SYSTEM, DIESEL
28
11037555
Date: 2026-09-26. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it.
11037560
Date: 2026-09-26. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI was created to help address the correct repair regarding a low coolant message on the DIC
11037253
Date: 2026-09-04. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
11035340
Date: 2026-07-21. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
PI to help diagnose A/C concern
11031511
Date: 2026-04-14. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This PI instructs technicians to inspect the ground plane on MD Silverado vehicles with DTC P251A
11030974
Date: 2026-04-01. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This preliminary information communicates information about how to determine if a wheel and tires size change is available.
11030091
Date: 2026-03-09. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.
11030092
Date: 2026-03-09. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.
11029950
Date: 2026-03-02. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This Preliminary information communicates to the field on how to diagnosis a GPS issue with the Telematic module with no DTC'ss
11027928
Date: 2026-01-29. Type: Service Bulletin/Repair Instructions. Systems: UNKNOWN OR OTHER.
This preliminary information communicates an issue with how to repair a brake fluid leak at the B356 Brake Pipe Pressure Switch connector.
Notes on this record
Complaints from the API and bulk file are merged and deduplicated by ODI number; the API alone misses records.
System and subsystem counts are numbers of distinct complaints, recalls or communications that name them. One record can name several systems, so shares across systems can add to more than 100 percent; a single share never exceeds 100 percent.
Recalls are counted once per campaign, investigations once per action and manufacturer communications once per NHTSA id, even when NHTSA lists several model names for the same record.
A sales denominator is a calendar-year proxy, not the population of vehicles still in use. Rates are copied from verified pipeline output.
NHTSA's complaints API and bulk file list no complaint for this make, model and model year in this data build.