No complaints are listed for the 2015 Gillig LOW Floor. NHTSA's API and bulk file list none in this build.
Data build 2026-10-09.
NHTSA lists this vehicle as GILLIG LOW FLOOR.
Model-generated complaint tags: No complaints are listed for tagging.
Recalls
See new recalls and investigations this week.
19 recalls. Showing the latest 10 of 19.
Date: 2022-04-25. Systems: ELECTRICAL SYSTEM.
Defect: Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
Consequence: The engine may be started unexpectedly, increasing the risk of injury to anyone nearby the engine compartment during maintenance operations.
Remedy: Dealers will update the software for the buses equipped with the Vanner Ultracapacitor system, and conduct a hard rewire for the buses equipped with the KBI system, free of charge. Owner notification letters were mailed on June 22, 2022. Owners may contact Gillig's customer service at 1-510-264-5073 for 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2020-07-02. Systems: STEERING.
Defect: Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
Consequence: A loss of power steering assist may increase the risk of crash.
Remedy: Gillig will notify owners, and dealers will replace the motor-pump assemblies, free of charge. The recall began August 13, 2020. Owners may contact Gillig customer service at 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2020-03-25. Systems: ELECTRICAL SYSTEM.
Defect: Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Consequence: With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Remedy: Gillig will notify owners, and dealers will replace the circuit breakers, free of charge. The recall began April 24, 2020. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2019-03-08. Systems: EXTERIOR LIGHTING.
Defect: Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
Consequence: A loss of headlights can reduce the driver's ability to see, increasing the risk of a crash.
Remedy: Gillig has notified owners, and dealers will install new back covers on the headlight buckets, free of charge. The recall began April 1, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2018-11-09. Systems: PARKING BRAKE, SERVICE BRAKES, AIR.
Defect: Gillig LLC (Gillig) is recalling certain 2013-2018 Gillig Low Floor transit buses equipped with disk brakes. The spring cage bolts on the air brakes may not be sufficiently tightened, reducing the effectiveness of the parking brake.
Consequence: Loose cage bolts may result in the bus rolling away when in the park position or a loss of braking ability if the service brake air pressure is lost while moving. Either condition may increase the risk of a crash.
Remedy: Gillig will notify owners, and dealers will tighten the spring cage bolts, free of charge. The recall began December 10, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2018-08-09. Systems: EXTERIOR LIGHTING.
Defect: Gillig LLC (Gillig) is recalling certain 2012-2018 Gillig Low Floor vehicles. The front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The mismatched flashing may confuse other drivers, increasing the risk of a crash.
Remedy: Gillig will notify the owner of the buses, and dealers will reprogram the turn signals with new software, free of charge. The recall began August 30, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2018-06-20. Systems: EXTERIOR LIGHTING.
Defect: Gillig LLC (Gillig) is recalling certain 2001-2018 Gillig Low Floor transit buses. The turn signals may flash slowly, reducing their visibility to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The reduced visibility of the turn signals can increase the risk of a crash.
Remedy: Gillig will notify owners, and dealers will update the software that controls the turn flash rate, free of charge. The recall began on August 2, 2018. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2017-09-08. Systems: STEERING.
Defect: Gillig LLC (Gillig) is recalling certain 2013-2016 Hybrid and all Electric Low Floor buses with electro-hydraulic power steering assist. The coupler between the high-voltage electric motor and hydraulic steering pump shafts may fail, resulting in a loss of power steering assist.
Consequence: A loss of power steering assist will cause the need for increased steering effort, increasing the risk of a crash.
Remedy: Gillig will notify owners, and dealers will replace the steering motor-pump assemblies, free of charge. The recall began on October 24, 2017. Owners may contact Gillig customer service at 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2017-04-19. Systems: SUSPENSION.
Defect: Gillig LLC (Gillig) is recalling certain 2015-2016 Low Floor transit buses equipped with Norgren-brand suspension kneeling modules. The suspension kneeling modules on these vehicles have snap rings on the solenoid valve pistons which may not have been fully inserted and seated during assembly, potentially affecting the suspension air bag pressure and the vehicle's suspension height.
Consequence: An unexpected loss of suspension air bag pressure while driving would result in an abrupt reduction in suspension height, potentially increasing the risk of a crash. A loss of suspension air bag pressure could also occur during vehicle servicing, increasing the risk of injury to maintenance personnel.
Remedy: Gillig will notify owners and pay fleets to inspect the front and rear kneeling modules. A snap ring reset tool will be provided free of charge to permanently seat the snap ring in the intended groove. The recall began on June 2, 2017. Owners may contact Gillig customer service at 1-800-735-1500.
Do not drive: No. Park outside: No.
Date: 2017-02-24. Systems: EXTERIOR LIGHTING.
Defect: Gillig LLC (Gillig) is recalling certain model year 1997-2017 Low Floor transit buses. The front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The reduced visibility of the turn signals may increase the risk of a crash.
Remedy: Gillig will notify owners, and dealers will install turn signals that have increased visibility. The recall began June 7, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Do not drive: No. Park outside: No.
Manufacturer communications
21 manufacturer communications.
Communications by system| System | Count |
|---|
| EQUIPMENT | 6 |
|---|
| STEERING | 5 |
|---|
| ELECTRICAL SYSTEM | 3 |
|---|
| EQUIPMENT ADAPTIVE/MOBILITY | 3 |
|---|
| ENGINE AND ENGINE COOLING | 2 |
|---|
| FUEL SYSTEM, OTHER | 2 |
|---|
| AIR BAGS | 1 |
|---|
| SERVICE BRAKES | 1 |
|---|
10161336
Date: 2019-05-28. Type: Service Bulletin/Repair Instructions. Systems: ELECTRICAL SYSTEM.
After a review of the fuse selection in some of your 2013 through 2015 Hybrid buses, Gillig determined that the fuses in the battery fuse box need to be changed.
10161335
Date: 2019-05-06. Type: Service Bulletin/Repair Instructions. Systems: ENGINE AND ENGINE COOLING.
Because of a supply issue with the blue hose covering, Eaton is temporarily making FC-300 hose using black covering. FC-300 hose assemblies made between October 2018 to May 2019 will be affected by this change.
10128595
Date: 2018-01-10. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
A procedure to properly adjust the draglink so the socket won't over articulate, causing increased wear.
10128594
Date: 2018-01-05. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
It was found that an earlier Bulletin spec'd bolts that could be too long due to variances in bolt shoulder length, so this bulletin was written to make sure bolt attachments were correct.
10117370
Date: 2017-08-22. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT ADAPTIVE/MOBILITY.
This field service bulletin is instructing vehicle owners and aftermarket part purchasers to remove the "Duck Bill" valves in the rear run box to prevent water intrapment, which can contribute to corrosion of some components. Owners are asked to permanently remove the duck bill valves from the rear
10117369
Date: 2017-08-08. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
This field service bulletin informs vehicle owners and aftermarket part purchasers that Gillig will be sending them parts and service instructions to upgrade the electric power steering pump systems on certain BAE Hybrid Low Floor buses. The bulletin details how a new pump-motor "swing unit" will be
10115288
Date: 2017-07-28. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT ADAPTIVE/MOBILITY, FUEL SYSTEM, OTHER.
This field service bulletin is informing vehicle owners and aftermarket part purchasers that the Pressure Relief Device (PRD) vent tube caps on Agility CNG systems are important to maintain to help prevent moisture and/or debris from causing the PRD to malfunction. The bulletin is clear that the exi
10115287
Date: 2017-07-06. Type: Service Bulletin/Repair Instructions. Systems: SUSPENSION.
This field service bulletin is informing vehicle owners and aftermarket part purchasers that NewayA?, a SAF-HOLLANDA? division, has identified some suspension installation and monitoring issues on the ADLSD-120 suspension used on 29' Gillig buses manufactured between 2007 and 2017. The following pro
10110362
Date: 2016-12-20. Type: Service Bulletin/Repair Instructions. Systems: STEERING.
Gillig has received reports of partial cracking in the steering gear mounting plate in some Low Floor buses. We are now requesting that owners of all Low Floor buses from model year 1997 through June, 2015 inspect the steering gear mounting plates per the instructions in this bulletin. Inspections s
10115971
Date: 2016-12-20. Type: Service Bulletin/Repair Instructions. Systems: EQUIPMENT, EQUIPMENT ADAPTIVE/MOBILITY, STEERING.
Gillig has received reports of partial cracking in the steering gear mounting plate in some Low Floor buses. We are now requesting that owners of all Low Floor buses from model year 1997 through June, 2015 inspect the steering gear mounting plates per the instructions in this bulletin. Inspections s